[Discussion] Typical prices for Phantom repairs & mods

[devil.L]

Yo Phantom Bros!!

How much would it cost to change the Piston Ring?? (Ta150)

 

noone changes just the piston ring itself.

to reach the piston ring, you've to open up th block.

opening up the block is as good as doing an overhaul.

 

if your piston ring is loose, its time to do an overhaul, with a new pistong ring of course.

[tankee1981]

My exhaust pipe is faulty and i think it affects my TA200's performance in terms of speed...my usual max speed is like 100km before the vibrations get too unbearable.

 

Ah Chong from Planet told me a brand new original will cost me $300 and can only order from Boon Siew. Another option is to get one from scrapped Phantoms which i have been waiting for long time from him.

 

I plan to renew COE at end of this year as TA200 is a cheap and reliable mode of personal transport. Pls advise on my exhaust pipe issue.

 

Lastly i will like to change the 4 chrome panels (2 on each side) plus the 2 pasted on logos on fuel tank as they are worn out and doesn't look nice. Where can i go to? Thanks

[MCARLOS]

noone changes just the piston ring itself.

to reach the piston ring, you've to open up th block.

opening up the block is as good as doing an overhaul.

 

if your piston ring is loose, its time to do an overhaul, with a new pistong ring of course.

 

Thanks Bro!! Just own a TA150 2mths Ago!! Newbie Here:D

[razali1980]

My exhaust pipe is faulty and i think it affects my TA200's performance in terms of speed...my usual max speed is like 100km before the vibrations get too unbearable.

 

Ah Chong from Planet told me a brand new original will cost me $300 and can only order from Boon Siew. Another option is to get one from scrapped Phantoms which i have been waiting for long time from him.

 

I plan to renew COE at end of this year as TA200 is a cheap and reliable mode of personal transport. Pls advise on my exhaust pipe issue.

 

Lastly i will like to change the 4 chrome panels (2 on each side) plus the 2 pasted on logos on fuel tank as they are worn out and doesn't look nice. Where can i go to? Thanks

 

Wah I got same problem like you...

[jtzx]

My exhaust pipe is faulty and i think it affects my TA200's performance in terms of speed...my usual max speed is like 100km before the vibrations get too unbearable.

 

Ah Chong from Planet told me a brand new original will cost me $300 and can only order from Boon Siew. Another option is to get one from scrapped Phantoms which i have been waiting for long time from him.

 

I plan to renew COE at end of this year as TA200 is a cheap and reliable mode of personal transport. Pls advise on my exhaust pipe issue.

 

Lastly i will like to change the 4 chrome panels (2 on each side) plus the 2 pasted on logos on fuel tank as they are worn out and doesn't look nice. Where can i go to? Thanks

 

It's best to try your luck with scrap yards man. They have lots and lots of 2nd hand pipes.

[Allen]

It's best to try your luck with scrap yards man. They have lots and lots of 2nd hand pipes.

 

Btw, where is scrap yards?

[m0bIlEnErD]

................

Edited April 4, 2011 by m0bIlEnErD

[Allen]

Btw, how much is it to change the ignition key?

[m0bIlEnErD]

Btw, how much is it to change the ignition key?

 

 

you mean cut a new key or change the lock?

[Allen]

you mean cut a new key or change the lock?

 

Lock, and new key i guess.. My friend can use my key turn on his phantom so is he key can turn on mine LOL. Abit not safe..

[hu-am-i]

anyone knows how much to install the blue LED speedo light ?

[tankee1981]

Wah I got same problem like you...

 

 

I mean i cannot even outrun a TA200 with pillion! Partially cos i scare all the 'clinging' sound will make it worst...

 

I have riders who pump 95 and have as good performance than mine...sianz

[Icomeforyou]

anyone knows how much to install the blue LED speedo light ?

 

The LED light all same type, generally $2-8, if i never remember wrongly, i don't remember paying more than $10, its only one bulb, got 4 colors btw, orange, white, blue and red. If you want, can also change yourself...

[jtzx]

NOOOO!!! dun get blue.. cause i'm blue already. try white la.. ;D

[wizardtan]

The LED light all same type, generally $2-8, if i never remember wrongly, i don't remember paying more than $10, its only one bulb, got 4 colors btw, orange, white, blue and red. If you want, can also change yourself...

 

There are 2 bulbs but my left side of the speedo blue is brighter than the right, no idea why, I have blue.

[xavez]

Repairs / Maintanence:

 

*Rear brake light relay wiring $12 @ Lee Huat Motor, near 10 Mile Junction

*Speedo Cable $17 @ Lee Huat

* Fuel Sensor $40 (Planet) custom 4 & above

* Battery $26Yuasa / $38(plug and play) (LAB) / $35 (Planet) / $48 (Ah Koon) / $60 woodlands road carltex (7Ah battery)

* Steering cone $55-65

* Chain Tensioner $55-60 (for tick tick sound at cold start)

* Chain Tensioner + Cam Chain + Gaskets + O-Rings + Chex 9000 EO = $277 (Eng Sin Motor - cck ave 1)

* Front brake disc $45

* Tyres (metz lasertec) $160 front & back (Planet) / $170 (HKL) / $155 (Unique Motorsports)

* Rear Tyre (Metz) $90 @ (Planet) / $89 (HKL)

* Chain $70-120 depending on type

* Chain + Sprocket - $140+/-

* DID O RING with Original Honda Sprocket - $130 (Planet)

* Signal lights - depending on which type you like. $8-25.

* Signal bulb, headlight bulb - 1 $ (LAB, easy DIY) (add on: approved brighter ones for $8. bought from koon.)

* Brake light bulb - $2 (Planet)

* Speedo BackLight + Workmanship (Planet) - S$2

* Headlight - anywhere from $35 to 90 depending the type you like.

* Spark plug - $2-20 [[ Replay once had his changed for S$2 ]]

* Engine oil - $6 -18 (jB got his lousiest EO for $3)

* Brake Pad $15-25

* Bleed and change brake fluid($10 each side)

* Air filter - $10

* K&N Air filter $85 (Unique Motorsports)

* Wheel ball bearings - $20-35 (depends on how mech chop u) jtzx: change for only $5 at planet

* Gear Shaft - $100 (planet)

* Clutch plate - $80 (Planet)

* Front fork (1 pair) - $330 (planet)

* Front fork seals (plus fork oil of course) - $65 (planet)

* Front fork tube (1 x) - $30 (planet)

* Rectifier - $75 (planet)

* Coil - $180 (planet)

* Rethreading of spark plug thread - between $35 - $45.

* Gasket - $30 (koon)

* Gasket @ Exhaust - $25 (Planet)

* Starter carbon - $60 (planet)

* Started Relay - $80 (Eng Sin Motor - cck ave 1)

* Front fender - $45 (original honda) ($28 at ah boy, DIY 4 screws only)

* Rear brake plate w/ pad $58 (planet)

* Rear brake disc - $80 (planet)

* Original rear suspension $180 (planet)

* Repair front brake pump (jam) and replace brake oil -$25 - (planet)

* Front brake pump - $50 (Unique motorsport)

* Rear Brake Pump ($85) (planet)

* Overhaul: Piston+Ring+Block+Top gasket+EO+Plug - ($380) - (planet)

* Rear brake light 12 v 5w/18w $1 (planet)

* Clutch cable - $15 (planet) / $20 (ah koon)

* Throttle cable - $12 (planet)

* Front Brake/Clutch Lever - $8 each(planet)

* Balancer [the 2 silver thingies at the edge of your handlebars] - $15 (planet)

* Front fender -$45 (AMK HL motors)

* Spark plug cap - $18 (planet)

* regina gold chain, front & rear honda sprockets with installation at ah boy- $120

* air suction valve - $60

* front brake pump + caliper + brake fluid - $60 (planet)

* side stand(2nd hand) (ong's motor at midview building) - $10 / brand new $20 (upper thomson road spc)

* Choke replacement - $18 (planet)

* Carb Adjustment screw + washers + spring - $9 (2nd hand at workshop along cck ave 1)

*IU unit base plate... for attaching to handbar.$20 (Jalan Bukit merah workshop)

 

Mods and Accessories:

 

* Steel brake Line 1 pc - SGD $80 (unique motors)

* Respray of bike, (front/rear mudguard + Tank) single color - $180 (H L Cycle)

* Wide handlebar (custom4 phantom type) - $38

* Wide Crashbar with mounting points for spotlights - $80

* Big Footrest - $60 madman - Pinkphantom.com

* Front\Rubber part - $5/piece @LAB

* Front\Metal base plate - $12/piece @LAB

* Rear\Eagle footrest - $25/pair @ LAB (just bought today, now is $30)

* Side box e21 - $90-180 / $180 as of April 2010 from LAB

* Zeus box 48L - $110 (Koon)

* Fuel tank - $382 contact madman or check http://www.pinkphantom.com/estore06.html

* Spotlights $35 a pair http://www.pinkphantom.com/estore11a.html

* Windshield $65-80

* Grips $10-120

* Chrome w/ rubber strips grips (LAB) - $25

* Mirrors $12(LAB) - $50 (jB got his, 8 bucks for small ones)

* Look-alike-original mirrors (shop beside LAB) - $20, LAB should be cheaper.

* small foldable square mirror - $45 (HKL)

* Saddlebags $98-190 madman - Pinkphantom.com

* Hazard light less than $10 if u fix&wire urself, $18-20 for mech installation [[ S$15 if Replay does it for you! ]]

* Relocating rear signals to license plate - $10 (planet)

* Relocating rear signals to license plate with bracket - $28 (LAB)

* Rear box $80-330

* Voltage stabiliser - $59-$120 depends

* Rider's ORIGINAL footrest (LAB) - S$18 per side, can be cheaper?

* Stainless steel screws for speedo, and side covers. 6 to change altogether. $1-$1.80 also bought from koon.

* washers to go at 50c each at regina

* Socket for supporting the head light - $15

* Bullet Headlight - $35 (LAB)

* Gear lever with rubber $20 at koon

* Chrome gear and brake levers set - madman

* Stebel Magnum 2 (Silver) w/o installation - $18-$20 (LAB)

* Daiso electric horns (pair) - $45 (planet)

* Phantom TA 200 gearbox - $540 (planet)

* Front fender the "mudflap"- $20 at koon

* Stebel Electric horn with nice hidden installation under front chrome cover- at koon $38

* Re-wrap seat- Starts from about $38 from Eugene saddledry, $25 basic one from Auntie Shop

* Spotlights on crashbar with installation- $35 at koon

* Crashbar- $65 from ah boy DIY

* Anchor and wide type crashbar - madman

* rear no. plate $10..first shop opposite rov..ubi

 

Still looking for Phantom Custom4 badge...

Gonna visit scrapyards soon. For those interested in getting the addresses...

http://www.onemotoring.com.sg/publish/onemotoring/en/lta_information_guidelines/de_register_a_vehicle/de-register/scrap_yard_operators.html

 

btw are the girls from auntie shop twin sisters? lol

[Allen]

hey, bros. my phantom brake pads like rubbing the disc.. i can hear the brake pad sound rubbing the brake disc..

 

where got good shop to recommend?

[Hydher]

phantom 2 shops. koon or planet are good.

[Allen]

phantom 2 shops. koon or planet are good.

 

koon? at where?

[Hydher]

redhill mrt lengkok bahru. bro should read up the pk's page. comprehensive info.

[Allen]

redhill mrt lengkok bahru. bro should read up the pk's page. comprehensive info.

 

Alright thanks cheers. ^^

[tankee1981]

I just bought one chrome panel (the left one under the fuel tank) from LAB yesterday for $29.

 

If buy exhaust pipe from scrap yard usually how much?

 

How do i know when to change my spark plug for TA200? There was once where it cannot start then towed to workshop, i want to avoid such case from happening again.

 

Thanks

Edited March 3, 2011 by tankee1981

[Icomeforyou]

Hey tankee, exhaust i not sure, but spark plug is roughly $3 - $5.

 

And one should last you easily 1-3 months, if need to change weekly (assuming) might be an underlying problem and not spark plug

[MCARLOS]

Bros!

Any of you know where to get the Cheap Motorcycle Jack? I want to to lub my chain but a bit diffucult cos it only have a side stand..

[kmjoe]

Hey tankee, exhaust i not sure, but spark plug is roughly $3 - $5.

 

And one should last you easily 1-3 months, if need to change weekly (assuming) might be an underlying problem and not spark plug

 

usually spark plug can last ard 15k as told be mech... mine have been usin it for about 10k and its still going well... i got a spare spark plug in my box just in case thou

 

Bros!

Any of you know where to get the Cheap Motorcycle Jack? I want to to lub my chain but a bit diffucult cos it only have a side stand..

 

not sure if i can say this, but some of us uses a oiler than we no longer need to suffer the pain in the ass lubing our chains...