[Discussion] Typical prices for Phantom repairs & mods

[VidaK]

Mine gear 5 got rattling sound so I think should be cui liao. Only at gear 5 and not other gears

 

ok you need to let ah chong try out your fifth gear... a good chance that your gear need to be replaced...

 

please do NOT use your fifth gear in the meantime... unless you want to overhaul your engine as well...

[gysmily]

Anyone changed your rear tyre to metz or pirelli at planet recently? How much is it? Thanks

 

$90.00 Metzeller.

[Binteng]

Any place other than planet to change metz tire for both front and back for cheap ?

[jtzx]

Repairs / Maintenance :

 

* Fuel Sensor $40 (Planet)custom 4 & above

* Battery $26Yuasa/$38(plug and play) (LAB) / $30-35 (Planet) / $48 (Ah Koon)/ $60 woodlands road carltex (7Ah battery)

* Steering cone $55-65

* Chain Tensioner $55-60 (for tick tick sound at cold start)

* Front brake disc $45

* Tyres (metz) $150 front & back

* Chain $70-120 depending on type

* Chain + Sprocket - $140+/-

* DID O RING with Original Honda Sprocket - $130 (Planet, did it this afternoon)

* Signal lights - depending on which type you like. $8-25.

* Signal bulb, headlight bulb - 1 $ (LAB, easy DIY) (add on: approved brighter ones for $8. bought from koon.)

* Speedo BackLight + Workmanship (Planet) - S$2

* Headlight - anywhere from $35 to 90 depending the type you like.

* Spark plug - $2-20 [[ Replay once had his changed for S$2 ]]

* Engine oil - $6 -18 (jB got his lousiest EO for $3)

* Brake Pad $15-25

* Bleed and change brake fluid($10 each side)

* Air filter - $10

* Wheel ball bearings - $20-35 (depends on how mech chop u) jtzx: change for only $5 at planet

* Gear Shaft - $100 (planet)

* Clutch plate - $80 (Planet)

* Front fork (1 pair) - $330 (planet)

* Front fork seals (plus fork oil of course) - $65 (planet)

* Front fork tube (1 x) - $30 (planet)

* Rectifier - $75 (planet)

* Coil - $180 (planet)

* Rethreading of spark plug thread - between $35 - $45.

* Gasket - $30 (koon)

* Starter carbon - $60 (planet)

* Front fender - $45 (original honda)

* Rear brake plate w/ pad $58 (planet)

* Rear brake disc - $80 (planet)

* Original rear suspension $180 (planet)

* Repair front brake pump (jam) and replace brake oil -$25 - (planet)

* Replace entire front brake pump ($80) - (planet)

* Rear Brake Pump ($85) (planet)

* Overhaul: Piston+Ring+Block+Top gasket+EO+Plug - ($380) - (planet)

* Rear brake light 12 v 5w/18w $1 (planet)

* Clutch cable - $15 (planet)

* Throttle cable - $12 (planet)

* Front Brake/Clutch Lever - $8 each(planet)

* Balancer[the 2 silver thingies at the edge of your handlebars] - $15 (planet)

* Front fender -$45 (AMK HL motors)

 

Mods and Accessories:

* Respray of bike, (front/rear mudguard + Tank) single color - $180 (H L Cycle)

* Wide handlebar (custom4 phantom type) - $38

* Wide Crashbar with mounting points for spotlights - $80

* Footrest - $65-85

- Front\Rubber part - $5/piece @LAB

- Front\Metal base plate - $11/piece @LAB

- Rear\Eagle footrest - $25/pair @ LAB

* Side box e21 - $90-130

* Fuel tank - $382 contact madman or check http://www.pinkphantom.com/estore06.html

* Spotlights $35 a pair http://www.pinkphantom.com/estore11a.html

* Windshield $65-80

* Grips $10-120

* Chrome w/ rubber strips grips (LAB) - $25

* Mirrors $12(LAB) - $50 (jB got his, 8 bucks for small ones)

* Look-alike-original mirrors (shop beside LAB) - $20, LAB should be cheaper.

* Saddlebags $110-180

* Hazard light less than $10 if u fix&wire urself, $18-20 for mech installation [[ S$15 if Replay does it for you! ]]

* Relocating rear signals to license plate - $10 (planet)

* Rear box $80-330

* Voltage stabiliser - $59-$120 depends

* Pillion's 'eagle' footrest w/o installation (LAB) - S$22

* Rider's ORIGINAL footrest (LAB) - S$18 per side, can be cheaper?

* Stainless steel screws for speedo, and side covers. 6 to change altogether. $1-$1.80 also bought from koon.

++ washers to go at 50c each at regina

* Socket for supporting the head light - $15

* Bullet Headlight - $35 (LAB)

* Gear lever with rubber $20 at koon

* Stebel Magnum 2 (Silver) w/o installation - $18-$20 (LAB)

* Daiso electric horns (pair) - $45 (planet)

* Phantom TA 200 gearbox - $540 (planet)

 

Tow Services & Send for Inspection:

 

* Towing (to and fro) - $40 (Planet)

* Send for inspection - $60 (Planet)

[VidaK]

Any place other than planet to change metz tire for both front and back for cheap ?

 

cheap...? you can try haggle with ah boy... but... at your own risk...

[Binteng]

wa. u talk like if i haggle with ahboy , something might happen sia . dont scared me leh.

[VidaK]

wa. u talk like if i haggle with ahboy , something might happen sia . dont scared me leh.

 

no LOL not the haggling part that is dangerous... is his workshop...

[ahcaibiker]

saded man...:cry: i just discovered a busted left fork seal on my TA150 probably sustained during the minor collison with the sp on friday night. Joshua will know what happened... although no fork oil was seen leaking even when i push down my fork. can see part of the seal is busted... went out for a ride with a few ppl this morning and didnt feel anything amiss... only discovered it when parking my bike and my eyes happened to glance at the front fork... anyone serviced the front fork and replaced the rubber seal before? what is the price like? no camera so cannot post a pic for you all to see...

[FMC]

Must be never regular change your EO....

[VidaK]

saded man...:cry: i just discovered a busted left fork seal on my TA150 probably sustained during the minor collison with the sp on friday night. Joshua will know what happened... although no fork oil was seen leaking even when i push down my fork. can see part of the seal is busted... went out for a ride with a few ppl this morning and didnt feel anything amiss... only discovered it when parking my bike and my eyes happened to glance at the front fork... anyone serviced the front fork and replaced the rubber seal before? what is the price like? no camera so cannot post a pic for you all to see...

 

to replace fork seal is about 60+... nevermind the incident since fork seal is a wear and tear part... have to be replaced regularly... oh yea and don't forget to state how stiff or how soft you would like your front forks to be... there are different weights of fork oil...

 

Must be never regular change your EO....

 

lol... which post are you referring to...

[tweakmax2]

Usually u all buy saddle bag from where, can it last for 2 yrs or withstand weather condition ? Any price and recommendation

[jtzx]

saded man...:cry: i just discovered a busted left fork seal on my TA150 probably sustained during the minor collison with the sp on friday night. Joshua will know what happened... although no fork oil was seen leaking even when i push down my fork. can see part of the seal is busted... went out for a ride with a few ppl this morning and didnt feel anything amiss... only discovered it when parking my bike and my eyes happened to glance at the front fork... anyone serviced the front fork and replaced the rubber seal before? what is the price like? no camera so cannot post a pic for you all to see...

 

to replace fork seal is about 60+... nevermind the incident since fork seal is a wear and tear part... have to be replaced regularly... oh yea and don't forget to state how stiff or how soft you would like your front forks to be... there are different weights of fork oil...

 

 

 

lol... which post are you referring to...

 

 

 

that little bang can damage your fork seal.. i don't think so nahz.. maybe its wear and tear....

 

so you got it replaced already???

[ahcaibiker]

that little bang can damage your fork seal.. i don't think so nahz.. maybe its wear and tear....

 

so you got it replaced already???

 

cos the point of impact zhun zhun kenna the fork seal area, i collided into the SP's exhaust end can tip. when observed closely, can see the scratches around the fork seal area. sian...

 

haven replace la, need to wait for pay day which is a week later. still able to ride normally w/o any unstability or strange vibrations. no fork oil leaking either. damping effect still there. just concerned that water might seep in during rainy weather.

[mepkoh]

saded man...:cry: i just discovered a busted left fork seal on my TA150 probably sustained during the minor collison with the sp on friday night. Joshua will know what happened... although no fork oil was seen leaking even when i push down my fork. can see part of the seal is busted... went out for a ride with a few ppl this morning and didnt feel anything amiss... only discovered it when parking my bike and my eyes happened to glance at the front fork... anyone serviced the front fork and replaced the rubber seal before? what is the price like? no camera so cannot post a pic for you all to see...

 

i think your damage is the seal dusk cover not the actual seal..

if the seal is busted..your fork will be oily by now the oil will turn into a nasty gooey black stuff .

[ahcaibiker]

i think your damage is the seal dusk cover not the actual seal..

if the seal is busted..your fork will be oily by now the oil will turn into a nasty gooey black stuff .

 

hmm, part of the black rubber part is confirmed all banged up and cracked. i push down my fork with force, rode it around, no signs of oil leakage at all. i see whether i can get hold of a camera then i post it here for u all to see.

[jianping]

Usually u all buy saddle bag from where, can it last for 2 yrs or withstand weather condition ? Any price and recommendation

 

I got mine from madman, u can also try to get from ah koon..

 

Can withstand weather quite well, have been using mine for nearly a year, only a bit of rust on metal parts, the bag still looks okok, no water will flow inside unless super heavy rain..

 

price wise ard $160 for medium ones, u can buy padlock to lock your stuff inside if u want.

 

You will need to relocate your signal light for the medium ones.

[jtzx]

Repairs / Maintenance :

 

* Fuel Sensor $40 (Planet)custom 4 & above

* Battery $26Yuasa/$38(plug and play) (LAB) / $35 (Planet) / $48 (Ah Koon)/ $60 woodlands road carltex (7Ah battery)

* Steering cone $55-65

* Chain Tensioner $55-60 (for tick tick sound at cold start)

* Front brake disc $45

* Tyres (metz) $150 front & back

* Chain $70-120 depending on type

* Chain + Sprocket - $140+/-

* DID O RING with Original Honda Sprocket - $130 (Planet, did it this afternoon)

* Signal lights - depending on which type you like. $8-25.

* Signal bulb, headlight bulb - 1 $ (LAB, easy DIY) (add on: approved brighter ones for $8. bought from koon.)

* Speedo BackLight + Workmanship (Planet) - S$2

* Headlight - anywhere from $35 to 90 depending the type you like.

* Spark plug - $2-20 [[ Replay once had his changed for S$2 ]]

* Engine oil - $6 -18 (jB got his lousiest EO for $3)

* Brake Pad $15-25

* Bleed and change brake fluid($10 each side)

* Air filter - $10

* Wheel ball bearings - $20-35 (depends on how mech chop u) jtzx: change for only $5 at planet

* Gear Shaft - $100 (planet)

* Clutch plate - $80 (Planet)

* Front fork (1 pair) - $330 (planet)

* Front fork seals (plus fork oil of course) - $65 (planet)

* Front fork tube (1 x) - $30 (planet)

* Rectifier - $75 (planet)

* Coil - $180 (planet)

* Rethreading of spark plug thread - between $35 - $45.

* Gasket - $30 (koon)

* Starter carbon - $60 (planet)

* Front fender - $45 (original honda)

* Rear brake plate w/ pad $58 (planet)

* Rear brake disc - $80 (planet)

* Original rear suspension $180 (planet)

* Repair front brake pump (jam) and replace brake oil -$25 - (planet)

* Replace entire front brake pump ($80) - (planet)

* Rear Brake Pump ($85) (planet)

* Overhaul: Piston+Ring+Block+Top gasket+EO+Plug - ($380) - (planet)

* Rear brake light 12 v 5w/18w $1 (planet)

* Clutch cable - $15 (planet)

* Throttle cable - $12 (planet)

* Front Brake/Clutch Lever - $8 each(planet)

* Balancer[the 2 silver thingies at the edge of your handlebars] - $15 (planet)

* Front fender -$45 (AMK HL motors)

 

Mods and Accessories:

* Respray of bike, (front/rear mudguard + Tank) single color - $180 (H L Cycle)

* Wide handlebar (custom4 phantom type) - $38

* Wide Crashbar with mounting points for spotlights - $80

* Footrest - $65-85

- Front\Rubber part - $5/piece @LAB

- Front\Metal base plate - $11/piece @LAB

- Rear\Eagle footrest - $25/pair @ LAB

* Side box e21 - $90-130

* Fuel tank - $382 contact madman or check http://www.pinkphantom.com/estore06.html

* Spotlights $35 a pair http://www.pinkphantom.com/estore11a.html

* Windshield $65-80

* Grips $10-120

* Chrome w/ rubber strips grips (LAB) - $25

* Mirrors $12(LAB) - $50 (jB got his, 8 bucks for small ones)

* Look-alike-original mirrors (shop beside LAB) - $20, LAB should be cheaper.

* Saddlebags $110-180

* Hazard light less than $10 if u fix&wire urself, $18-20 for mech installation [[ S$15 if Replay does it for you! ]]

* Relocating rear signals to license plate - $10 (planet)

* Rear box $80-330

* Voltage stabiliser - $59-$120 depends

* Pillion's 'eagle' footrest w/o installation (LAB) - S$22

* Rider's ORIGINAL footrest (LAB) - S$18 per side, can be cheaper?

* Stainless steel screws for speedo, and side covers. 6 to change altogether. $1-$1.80 also bought from koon.

++ washers to go at 50c each at regina

* Socket for supporting the head light - $15

* Bullet Headlight - $35 (LAB)

* Gear lever with rubber $20 at koon

* Stebel Magnum 2 (Silver) w/o installation - $18-$20 (LAB)

* Daiso electric horns (pair) - $45 (planet)

* Phantom TA 200 gearbox - $540 (planet)

 

Tow Services & Send for Inspection:

 

* Towing (to and fro) - $40 (Planet)

* Send for inspection - $60 (Planet)

[ifourdesign]

Anybody know if i can customize a tank bra for phantom? price range around how much? got alot of dents on my bike, lazy to repair and respray. =)

[jeffrey83]

hi guys, any items named "AIR TENSION" for Phantom?

[VidaK]

hi guys, any items named "AIR TENSION" for Phantom?

 

hmmm... not that I heard of... roughly what it is supposed to be...?

[FSbiker]

My 150cc Phantom wheel alignment is slightly out, any idea how much it costs to realign? Thanks

[VidaK]

My 150cc Phantom wheel alignment is slightly out, any idea how much it costs to realign? Thanks

 

roughly one kopi...

 

(of course I am not referring to myself, but ah chong of plan**)

[FSbiker]

roughly one kopi...

 

(of course I am not referring to myself, but ah chong of plan**)

 

 

Really?My friend told me it might cost quite a bit

[dogshit2]

Really?My friend told me it might cost quite a bit

 

Wheel alignment causes $80 at GNG motors.... Must leave bike overnight....

 

I might have some wheel alignment problem also...

[VidaK]

Really?My friend told me it might cost quite a bit

 

Wheel alignment causes $80 at GNG motors.... Must leave bike overnight....

 

I might have some wheel alignment problem also...

 

I think you two are referring to wheel bearing instead...