[Discussion] Typical prices for Phantom repairs & mods

[Allen]

Thanks for the reply guys as my 2t pipe leak again.... Will head down planet soon!

[jtzx]

yes this can be used.

 

Hi Guys, had bought a Phantom TA200 today but not collect yet.

 

I would like to know what kind of Spark plug do Phantom use?

 

Can use NGK racing spark?

http://www.af1racing.com/store/ProdImages/ngkrace.jpg

[jtzx]

LIst of prices

*Rear brake light relay wiring $12 @ Lee Huat Motor, near 10 Mile Junction

*Speedo Cable $17 @ Lee Huat

* Fuel Sensor $40 (Planet) custom 4 & above

* Battery $38 Yuasa / $38(plug and play) (LAB) / $35 (Planet) / $48 (Ah Koon) / $60 woodlands road carltex (7Ah battery)

* Steering cone $55-65

* Chain Tensioner $55-60 (for tick tick sound at cold start)

* Chain Tensioner + Cam Chain + Gaskets + O-Rings + Chex 9000 EO = $277 (Eng Sin Motor - cck ave 1)

* Front brake disc $45

* Tyres (metz lasertec) $160 front & back (Planet) / $170 (HKL) / $155 (Unique Motorsports) / $130 (LAB)

* Rear Tyre (Metz) $90 @ (Planet) / $89 (HKL)

* Chain $70-120 depending on type

* Chain + Sprocket - $140+/-

* DID O RING with Original Honda Sprocket - $130 (Planet)

* Signal lights - depending on which type you like. $8-25.

* Signal bulb, headlight bulb - 1 $ (LAB, easy DIY) (add on: approved brighter ones for $8. bought from koon.)

* Brake light bulb - $2 (Planet)

* Speedo BackLight + Workmanship (Planet) - S$2

* Headlight - anywhere from $35 to 90 depending the type you like.

* Spark plug - $2-20 [[ Replay once had his changed for S$2 ]]

* Engine oil - $6 -18 (jB got his lousiest EO for $3)

* Brake Pad $15-25

* Bleed and change brake fluid($10 each side)

* Air filter - $10

* K&N Air filter $85 (Unique Motorsports)

* Wheel ball bearings - $20-35 (depends on how mech chop u) jtzx: change for only $5 at planet

* Gear Shaft - $100 (planet)

* Clutch plate - $80 (Planet)

* Front fork (1 pair) - $330 (planet)

* Front fork seals (plus fork oil of course) - $65 (planet)

* Front fork tube (1 x) - $30 (planet) $60 x 01 now

* Rectifier - $75(new) $25(2nd hand) (planet)

* Coil - $180 (planet)

* Rethreading of spark plug thread - between $35 - $45.

* Gasket - $30 (koon)

* Gasket @ Exhaust - $25 (Planet)

* Starter carbon - $60 (planet)

* Started Relay - $80 (Eng Sin Motor - cck ave 1)

* Front fender - $45 (original honda) ($28 at ah boy, DIY 4 screws only)

* Rear brake plate w/ pad $58 (planet)

* Rear brake disc - $80 (planet)

* Original rear suspension $180 (planet)

* Repair front brake pump (jam) and replace brake oil -$25 - (planet)

* Front brake pump - $50 (Unique motorsport) $70 08/11

* Front brake rebuild - $35 08/11

* Rear Brake Pump ($85) (planet)

* Overhaul: Piston+Ring+Block+Top gasket+EO+Plug - ($380) - (planet)

* Rear brake light 12 v 5w/18w $1 (planet)

* Clutch cable - $15 (planet) / $20 (ah koon)

* Throttle cable - $12 (planet)

* Front Brake/Clutch Lever - $8 each(planet)

* Balancer [the 2 silver thingies at the edge of your handlebars] - $15 (planet)

* Front fender -$45 (AMK HL motors)

* Spark plug cap - $18 (planet)

* regina gold chain, front & rear honda sprockets with installation at ah boy- $120

* air suction valve - $60

* front brake pump + caliper + brake fluid - $60 (planet)

* side stand(2nd hand) (ong's motor at midview building) - $10 / brand new $20 (upper thomson road spc)

* Choke replacement - $18 (planet)

* Carb Adjustment screw + washers + spring - $9 (2nd hand at workshop along cck ave 1)

*IU unit base plate... for attaching to handbar.$20 (Jalan Bukit merah workshop)

*Chain roller guide - $5 DIY (buy from Eversuccess at Lembu Rd)

*Speedo casing rubber lining - $10 (Eng Sin Motor - cck ave1)

 

Mods and Accessories:

 

* Steel brake Line 1 pc - SGD $80 (unique motors)

* Respray of bike, (front/rear mudguard + Tank) single color - $180 (H L Cycle)

* Wide handlebar (custom4 phantom type) - $38

* Wide Crashbar with mounting points for spotlights - $80

* Big Footrest - $60 madman - Pinkphantom.com

* Front\Rubber part - $5/piece @LAB

* Front\Metal base plate - $12/piece @LAB

* Rear\Eagle footrest - $25/pair @ LAB (just bought today, now is $30)

* Side box e21 - $90-180 / $180 as of April 2010 from LAB

* Zeus box 48L - $110 (Koon)

* Fuel tank - $382 contact madman or check http://www.pinkphantom.com/estore06.html

* Spotlights $35 a pair http://www.pinkphantom.com/estore11a.html

* Windshield $65-80

* Grips $10-120

* Chrome w/ rubber strips grips (LAB) - $25

* Mirrors $12(LAB) - $50 (jB got his, 8 bucks for small ones)

* Look-alike-original mirrors (shop beside LAB) - $20, LAB should be cheaper.

* small foldable square mirror - $45 (HKL)

* Saddlebags $98-190 madman - Pinkphantom.com

* Hazard light less than $10 if u fix&wire urself, $18-20 for mech installation [[ S$15 if Replay does it for you! ]]

* Relocating rear signals to license plate - $10 (planet)

* Relocating rear signals to license plate with bracket - $28 (LAB)

* Rear box $80-330

* Voltage stabiliser - $59-$120 depends

* Rider's ORIGINAL footrest (LAB) - S$18 per side, can be cheaper?

* Stainless steel screws for speedo, and side covers. 6 to change altogether. $1-$1.80 also bought from koon.

* washers to go at 50c each at regina

* Socket for supporting the head light - $15

* Bullet Headlight - $35 (LAB)

* Gear lever with rubber $20 at koon

* Chrome gear and brake levers set - madman

* Stebel Magnum 2 (Silver) w/o installation - $18-$20 (LAB)

* Daiso electric horns (pair) - $45 (planet)

* Phantom TA 200 gearbox - $540 (planet)

* Front fender the "mudflap"- $20 at koon

* Stebel Electric horn with nice hidden installation under front chrome cover- at koon $38

* Re-wrap seat- Starts from about $38 from Eugene saddledry, $25 basic one from Auntie Shop

* Spotlights on crashbar with installation- $35 at koon

* Crashbar- $65 from ah boy DIY

* Anchor and wide type crashbar - madman

* rear no. plate $10..first shop opposite rov..ubi

* 6" Risers - $80 from Auntie Shop in Ubi

[osxunix]

How much is forks straightening cost someone bang my bike (Hit and run)?

Send for repair @ $120!

[Allen]

Does anyone know can phantom signal light do like 2a bike always on?

[naim]

Can. Use s4 signal light. But nt adviceable cux our charging system is very weak. I got a lower charging voltage running it, so dumped d idea. Urs cud be different. Still can la, but use a voltmeter n check.

[Allen]

Can. Use s4 signal light. But nt adviceable cux our charging system is very weak. I got a lower charging voltage running it, so dumped d idea. Urs cud be different. Still can la, but use a voltmeter n check.

 

I saw one uncle with the front one like S4, but i would like to do behind cause my bike is in black colour and i feel that it's for safety reason also.

[jevan]

Does anyone know can phantom signal light do like 2a bike always on?

 

can. i did it with mine. stock signal lights. but for the front. im not sure if can do for back. text me, i nowadays seldom on forum.

[Jestino]

hey guys how much is 2nd Hand exhaust pipe for Phantom ta200? Coz i just realised that right after the bend of the exhaust, got 1 hole. Air is flowing out from there when engine is running.

[nitsua]

hey guys how much is 2nd Hand exhaust pipe for Phantom ta200? Coz i just realised that right after the bend of the exhaust, got 1 hole. Air is flowing out from there when engine is running.

 

It’s for water to leak out, no worries.

[Jestino]

It’s for water to leak out, no worries.

 

Are you sure bro? The hole is before the the exhaust pipe, its at the exhaust header. Anyway thanks for your reply thou. =)

[fiz_ism]

Are you sure bro? The hole is before the the exhaust pipe, its at the exhaust header. Anyway thanks for your reply thou. =)

 

I encountered the same problem. It's more like a crack than a hole at the exhaust header. I know ah chong can weld those "holes" but how much does it cost? Thanks in advance guys!

[nitsua]

Sorry, I thought you meant the lowest point in the center, under the exhaust where the muffler began, where there is an ugly circular weld mark - the hole I was referring to was that. I thought mine leak too when I felt the exhaust air blown on my feet and leafs on the floor got blown away. I checked with Ah Koon, he told me its normal, to let water leak out. Then I look again where that hole is, makes sense.

[cherryE10]

LIst of prices

*Rear brake light relay wiring $12 @ Lee Huat Motor, near 10 Mile Junction

*Speedo Cable $17 @ Lee Huat

* Fuel Sensor $40 (Planet) custom 4 & above

* Battery $38 Yuasa / $38(plug and play) (LAB) / $35 (Planet) / $48 (Ah Koon) / $60 woodlands road carltex (7Ah battery)

* Steering cone $55-65

* Chain Tensioner $55-60 (for tick tick sound at cold start)

* Chain Tensioner + Cam Chain + Gaskets + O-Rings + Chex 9000 EO = $277 (Eng Sin Motor - cck ave 1)

* Front brake disc $45

* Tyres (metz lasertec) $160 front & back (Planet) / $170 (HKL) / $155 (Unique Motorsports) / $130 (LAB)

* Rear Tyre (Metz) $90 @ (Planet) / $89 (HKL)

* Chain $70-120 depending on type

* Chain + Sprocket - $140+/-

* DID O RING with Original Honda Sprocket - $130 (Planet)

* Signal lights - depending on which type you like. $8-25.

* Signal bulb, headlight bulb - 1 $ (LAB, easy DIY) (add on: approved brighter ones for $8. bought from koon.)

* Brake light bulb - $2 (Planet)

* Speedo BackLight + Workmanship (Planet) - S$2

* Headlight - anywhere from $35 to 90 depending the type you like.

* Spark plug - $2-20 [[ Replay once had his changed for S$2 ]]

* Engine oil - $6 -18 (jB got his lousiest EO for $3)

* Brake Pad $15-25

* Bleed and change brake fluid($10 each side)

* Air filter - $10

* K&N Air filter $85 (Unique Motorsports)

* Wheel ball bearings - $20-35 (depends on how mech chop u) jtzx: change for only $5 at planet

* Gear Shaft - $100 (planet)

* Clutch plate - $80 (Planet)

* Front fork (1 pair) - $330 (planet)

* Front fork seals (plus fork oil of course) - $65 (planet)

* Front fork tube (1 x) - $30 (planet) $60 x 01 now

* Rectifier - $75(new) $25(2nd hand) (planet)

* Coil - $180 (planet)

* Rethreading of spark plug thread - between $35 - $45.

* Gasket - $30 (koon)

* Gasket @ Exhaust - $25 (Planet)

* Starter carbon - $60 (planet)

* Started Relay - $80 (Eng Sin Motor - cck ave 1)

* Front fender - $45 (original honda) ($28 at ah boy, DIY 4 screws only)

* Rear brake plate w/ pad $58 (planet)

* Rear brake disc - $80 (planet)

* Original rear suspension $180 (planet)

* Repair front brake pump (jam) and replace brake oil -$25 - (planet)

* Front brake pump - $50 (Unique motorsport) $70 08/11

* Front brake rebuild - $35 08/11

* Rear Brake Pump ($85) (planet)

* Overhaul: Piston+Ring+Block+Top gasket+EO+Plug - ($380) - (planet)

* Rear brake light 12 v 5w/18w $1 (planet)

* Clutch cable - $15 (planet) / $20 (ah koon)

* Throttle cable - $12 (planet)

* Front Brake/Clutch Lever - $8 each(planet)

* Balancer [the 2 silver thingies at the edge of your handlebars] - $15 (planet)

* Front fender -$45 (AMK HL motors)

* Spark plug cap - $18 (planet)

* regina gold chain, front & rear honda sprockets with installation at ah boy- $120

* air suction valve - $60

* front brake pump + caliper + brake fluid - $60 (planet)

* side stand(2nd hand) (ong's motor at midview building) - $10 / brand new $20 (upper thomson road spc)

* Choke replacement - $18 (planet)

* Carb Adjustment screw + washers + spring - $9 (2nd hand at workshop along cck ave 1)

*IU unit base plate... for attaching to handbar.$20 (Jalan Bukit merah workshop)

*Chain roller guide - $5 DIY (buy from Eversuccess at Lembu Rd)

*Speedo casing rubber lining - $10 (Eng Sin Motor - cck ave1)

 

Mods and Accessories:

 

* Steel brake Line 1 pc - SGD $80 (unique motors)

* Respray of bike, (front/rear mudguard + Tank) single color - $180 (H L Cycle)

* Wide handlebar (custom4 phantom type) - $38

* Wide Crashbar with mounting points for spotlights - $80

* Big Footrest - $60 madman - Pinkphantom.com

* Front\Rubber part - $5/piece @LAB

* Front\Metal base plate - $12/piece @LAB

* Rear\Eagle footrest - $25/pair @ LAB (just bought today, now is $30)

* Side box e21 - $90-180 / $180 as of April 2010 from LAB

* Zeus box 48L - $110 (Koon)

* Fuel tank - $382 contact madman or check http://www.pinkphantom.com/estore06.html

* Spotlights $35 a pair http://www.pinkphantom.com/estore11a.html

* Windshield $65-80

* Grips $10-120

* Chrome w/ rubber strips grips (LAB) - $25

* Mirrors $12(LAB) - $50 (jB got his, 8 bucks for small ones)

* Look-alike-original mirrors (shop beside LAB) - $20, LAB should be cheaper.

* small foldable square mirror - $45 (HKL)

* Saddlebags $98-190 madman - Pinkphantom.com

* Hazard light less than $10 if u fix&wire urself, $18-20 for mech installation [[ S$15 if Replay does it for you! ]]

* Relocating rear signals to license plate - $10 (planet)

* Relocating rear signals to license plate with bracket - $28 (LAB)

* Rear box $80-330

* Voltage stabiliser - $59-$120 depends

* Rider's ORIGINAL footrest (LAB) - S$18 per side, can be cheaper?

* Stainless steel screws for speedo, and side covers. 6 to change altogether. $1-$1.80 also bought from koon.

* washers to go at 50c each at regina

* Socket for supporting the head light - $15

* Bullet Headlight - $35 (LAB)

* Gear lever with rubber $20 at koon

* Chrome gear and brake levers set - madman

* Stebel Magnum 2 (Silver) w/o installation - $18-$20 (LAB)

* Daiso electric horns (pair) - $45 (planet)

* Phantom TA 200 gearbox - $540 (planet)

* Front fender the "mudflap"- $20 at koon

* Stebel Electric horn with nice hidden installation under front chrome cover- at koon $38

* Re-wrap seat- Starts from about $38 from Eugene saddledry, $25 basic one from Auntie Shop

* Spotlights on crashbar with installation- $35 at koon

* Crashbar- $65 from ah boy DIY

* Anchor and wide type crashbar - madman

* rear no. plate $10..first shop opposite rov..ubi

* 6" Risers - $80 from Auntie Shop in Ubi

 

Do any of those shops mentioned ship to europe? Mine is the only european country where the phantom was imported and I am one of the handful of owners I am looking for customised aftermarket parts.

Thanks

[wwen.eric]

Hi guys, does anyone know how much will a 2nd hand tank cost?

[devil.L]

$50. i have one. lol.

[byon]

anybody selling their stock mirrors?

[Nick_Lee]

Anyone knows where I can get windshields? Ah boy or planet? Anyone knows the price?

[Tanarthur]

Less than 100 ah boy.... or pinkphantom.com

[Nick_Lee]

Less than 100 ah boy.... or pinkphantom.com

thanks... anyone knows if it is possible to install cb400 headlights onto ta200?

[Tanarthur]

Yes. Someone done it before.

[Nick_Lee]

Yes. Someone one it before.

any idea which shop i can visit to get the headlights? ah boy?

[byon]

any idea which shop i can visit to get the headlights? ah boy?

 

Planet's has one china CB400 headlight, legal, that shines as bright as Revo's headlight. $60 or $80 if i didnt recall wrongly.

Edited February 26, 2012 by byon

[hondajazz]

Hi, I am new in this forum. I just brought a 9 year old phantom ta200 and would like to look for a second hand crash bar. Anyone who wish to scrape their phantom bike please PM me for offer price. Thank you.

[naim]

ADDED CHAIN GUARD

 

*Rear brake light relay wiring $12 @ Lee Huat Motor, near 10 Mile Junction

*Speedo Cable $17 @ Lee Huat

* Fuel Sensor $40 (Planet) custom 4 & above

* Battery $38 Yuasa / $38(plug and play) (LAB) / $35 (Planet) / $48 (Ah Koon) / $60 woodlands road carltex (7Ah battery)

* Steering cone $55-65

* Chain Tensioner $55-60 (for tick tick sound at cold start)

* Chain Tensioner + Cam Chain + Gaskets + O-Rings + Chex 9000 EO = $277 (Eng Sin Motor - cck ave 1)

* Front brake disc $45

* Tyres (metz lasertec) $160 front & back (Planet) / $170 (HKL) / $155 (Unique Motorsports) / $130 (LAB)

* Rear Tyre (Metz) $90 @ (Planet) / $89 (HKL)

* Chain $70-120 depending on type

* Chain + Sprocket - $140+/-

* DID O RING with Original Honda Sprocket - $130 (Planet)

* Signal lights - depending on which type you like. $8-25.

* Signal bulb, headlight bulb - 1 $ (LAB, easy DIY) (add on: approved brighter ones for $8. bought from koon.)

* Brake light bulb - $2 (Planet)

* Speedo BackLight + Workmanship (Planet) - S$2

* Headlight - anywhere from $35 to 90 depending the type you like.

* Spark plug - $2-20 [[ Replay once had his changed for S$2 ]]

* Engine oil - $6 -18 (jB got his lousiest EO for $3)

* Brake Pad $15-25

* Bleed and change brake fluid($10 each side)

* Air filter - $10

* K&N Air filter $85 (Unique Motorsports)

* Wheel ball bearings - $20-35 (depends on how mech chop u) jtzx: change for only $5 at planet

* Gear Shaft - $100 (planet)

* Clutch plate - $80 (Planet)

* Front fork (1 pair) - $330 (planet)

* Front fork seals (plus fork oil of course) - $65 (planet)

* Front fork tube (1 x) - $30 (planet) $60 x 01 now

* Rectifier - $75(new) $25(2nd hand) (planet)

* Coil - $180 (planet)

* Rethreading of spark plug thread - between $35 - $45.

* Gasket - $30 (koon)

* Gasket @ Exhaust - $25 (Planet)

* Starter carbon - $60 (planet)

* Started Relay - $80 (Eng Sin Motor - cck ave 1)

* Front fender - $45 (original honda) ($28 at ah boy, DIY 4 screws only)

* Rear brake plate w/ pad $58 (planet)

* Rear brake disc - $80 (planet)

* Original rear suspension $180 (planet)

* Repair front brake pump (jam) and replace brake oil -$25 - (planet)

* Front brake pump - $50 (Unique motorsport) $70 08/11

* Front brake rebuild - $35 08/11

* Rear Brake Pump ($85) (planet)

* Overhaul: Piston+Ring+Block+Top gasket+EO+Plug - ($380) - (planet)

* Rear brake light 12 v 5w/18w $1 (planet)

* Clutch cable - $15 (planet) / $20 (ah koon)

* Throttle cable - $12 (planet)

* Front Brake/Clutch Lever - $8 each(planet)

* Balancer [the 2 silver thingies at the edge of your handlebars] - $15 (planet)

* Front fender -$45 (AMK HL motors)

* Spark plug cap - $18 (planet)

* regina gold chain, front & rear honda sprockets with installation at ah boy- $120

* air suction valve - $60

* front brake pump + caliper + brake fluid - $60 (planet)

* side stand(2nd hand) (ong's motor at midview building) - $10 / brand new $20 (upper thomson road spc)

* Choke replacement - $18 (planet)

* Carb Adjustment screw + washers + spring - $9 (2nd hand at workshop along cck ave 1)

*IU unit base plate... for attaching to handbar.$20 (Jalan Bukit merah workshop)

*Chain roller guide - $5 DIY (buy from Eversuccess at Lembu Rd)

*Speedo casing rubber lining - $10 (Eng Sin Motor - cck ave1)

*Chain Guard - $30 (Eversuccess)

 

Mods and Accessories:

 

* Steel brake Line 1 pc - SGD $80 (unique motors)

* Respray of bike, (front/rear mudguard + Tank) single color - $180 (H L Cycle)

* Wide handlebar (custom4 phantom type) - $38

* Wide Crashbar with mounting points for spotlights - $80

* Big Footrest - $60 madman - Pinkphantom.com

* Front\Rubber part - $5/piece @LAB

* Front\Metal base plate - $12/piece @LAB

* Rear\Eagle footrest - $25/pair @ LAB (just bought today, now is $30)

* Side box e21 - $90-180 / $180 as of April 2010 from LAB

* Zeus box 48L - $110 (Koon)

* Fuel tank - $382 contact madman or check http://www.pinkphantom.com/estore06.html

* Spotlights $35 a pair http://www.pinkphantom.com/estore11a.html

* Windshield $65-80

* Grips $10-120

* Chrome w/ rubber strips grips (LAB) - $25

* Mirrors $12(LAB) - $50 (jB got his, 8 bucks for small ones)

* Look-alike-original mirrors (shop beside LAB) - $20, LAB should be cheaper.

* small foldable square mirror - $45 (HKL)

* Saddlebags $98-190 madman - Pinkphantom.com

* Hazard light less than $10 if u fix&wire urself, $18-20 for mech installation [[ S$15 if Replay does it for you! ]]

* Relocating rear signals to license plate - $10 (planet)

* Relocating rear signals to license plate with bracket - $28 (LAB)

* Rear box $80-330

* Voltage stabiliser - $59-$120 depends

* Rider's ORIGINAL footrest (LAB) - S$18 per side, can be cheaper?

* Stainless steel screws for speedo, and side covers. 6 to change altogether. $1-$1.80 also bought from koon.

* washers to go at 50c each at regina

* Socket for supporting the head light - $15

* Bullet Headlight - $35 (LAB)

* Gear lever with rubber $20 at koon

* Chrome gear and brake levers set - madman

* Stebel Magnum 2 (Silver) w/o installation - $18-$20 (LAB)

* Daiso electric horns (pair) - $45 (planet)

* Phantom TA 200 gearbox - $540 (planet)

* Front fender the "mudflap"- $20 at koon

* Stebel Electric horn with nice hidden installation under front chrome cover- at koon $38

* Re-wrap seat- Starts from about $38 from Eugene saddledry, $25 basic one from Auntie Shop

* Spotlights on crashbar with installation- $35 at koon

* Crashbar- $65 from ah boy DIY

* Anchor and wide type crashbar - madman

* rear no. plate $10..first shop opposite rov..ubi

* 6" Risers - $80 from Auntie Shop in Ubi