[Discussion] Typical prices for Phantom repairs & mods

[Allen]

When planet open? Tomorrow I'm going.

[J.C]

Repairs / Maintanence:

 

*Rear brake light relay wiring $12 @ Lee Huat Motor, near 10 Mile Junction

*Speedo Cable $17 @ Lee Huat

* Fuel Sensor $40 (Planet) custom 4 & above

* Battery $26Yuasa / $38(plug and play) (LAB) / $35 (Planet) / $48 (Ah Koon) / $60 woodlands road carltex (7Ah battery)

* Steering cone $55-65

* Chain Tensioner $55-60 (for tick tick sound at cold start)

* Chain Tensioner + Cam Chain + Gaskets + O-Rings + Chex 9000 EO = $277 (Eng Sin Motor - cck ave 1)

* Front brake disc $45

* Tyres (metz lasertec) $160 front & back (Planet) / $170 (HKL) / $155 (Unique Motorsports)

* Rear Tyre (Metz) $90 @ (Planet) / $89 (HKL)

* Chain $70-120 depending on type

* Chain + Sprocket - $140+/-

* DID O RING with Original Honda Sprocket - $130 (Planet)

* Signal lights - depending on which type you like. $8-25.

* Signal bulb, headlight bulb - 1 $ (LAB, easy DIY) (add on: approved brighter ones for $8. bought from koon.)

* Brake light bulb - $2 (Planet)

* Speedo BackLight + Workmanship (Planet) - S$2

* Headlight - anywhere from $35 to 90 depending the type you like.

* Spark plug - $2-20 [[ Replay once had his changed for S$2 ]]

* Engine oil - $6 -18 (jB got his lousiest EO for $3)

* Brake Pad $15-25

* Bleed and change brake fluid($10 each side)

* Air filter - $10

* K&N Air filter $85 (Unique Motorsports)

* Wheel ball bearings - $20-35 (depends on how mech chop u) jtzx: change for only $5 at planet

* Gear Shaft - $100 (planet)

* Clutch plate - $80 (Planet)

* Front fork (1 pair) - $330 (planet)

* Front fork seals (plus fork oil of course) - $65 (planet)

* Front fork tube (1 x) - $30 (planet)

* Rectifier - $75 (planet)

* Coil - $180 (planet)

* Rethreading of spark plug thread - between $35 - $45.

* Gasket - $30 (koon)

* Gasket @ Exhaust - $25 (Planet)

* Starter carbon - $60 (planet)

* Started Relay - $80 (Eng Sin Motor - cck ave 1)

* Front fender - $45 (original honda) ($28 at ah boy, DIY 4 screws only)

* Rear brake plate w/ pad $58 (planet)

* Rear brake disc - $80 (planet)

* Original rear suspension $180 (planet)

* Repair front brake pump (jam) and replace brake oil -$25 - (planet)

* Front brake pump - $50 (Unique motorsport)

* Rear Brake Pump ($85) (planet)

* Overhaul: Piston+Ring+Block+Top gasket+EO+Plug - ($380) - (planet)

* Rear brake light 12 v 5w/18w $1 (planet)

* Clutch cable - $15 (planet) / $20 (ah koon)

* Throttle cable - $12 (planet)

* Front Brake/Clutch Lever - $8 each(planet)

* Balancer [the 2 silver thingies at the edge of your handlebars] - $15 (planet)

* Front fender -$45 (AMK HL motors)

* Spark plug cap - $18 (planet)

* regina gold chain, front & rear honda sprockets with installation at ah boy- $120

* air suction valve - $60

* front brake pump + caliper + brake fluid - $60 (planet)

* side stand(2nd hand) (ong's motor at midview building) - $10 / brand new $20 (upper thomson road spc)

* side stand (New) - $12 (Eversucess) DIY

* Choke replacement - $18 (planet)

* Carb Adjustment screw + washers + spring - $9 (2nd hand at workshop along cck ave 1)

*IU unit base plate... for attaching to handbar.$20 (Jalan Bukit merah workshop)

 

Mods and Accessories:

 

* Steel brake Line 1 pc - SGD $80 (unique motors)

* Respray of bike, (front/rear mudguard + Tank) single color - $180 (H L Cycle)

* Wide handlebar (custom4 phantom type) - $38

* Wide Crashbar with mounting points for spotlights - $80

* Big Footrest - $60 madman - Pinkphantom.com

* Front\Rubber part - $5/piece @LAB

* Front\Metal base plate - $12/piece @LAB

* Rear\Eagle footrest - $25/pair @ LAB (just bought today, now is $30)

* Side box e21 - $90-180 / $180 as of April 2010 from LAB

* Zeus box 48L - $110 (Koon)

* Fuel tank - $382 contact madman or check http://www.pinkphantom.com/estore06.html

* Spotlights $35 a pair http://www.pinkphantom.com/estore11a.html

* Windshield $65-80

* Grips $10-120

* Chrome w/ rubber strips grips (LAB) - $25

* Mirrors $12(LAB) - $50 (jB got his, 8 bucks for small ones)

* Look-alike-original mirrors (shop beside LAB) - $20, LAB should be cheaper.

* small foldable square mirror - $45 (HKL)

* Saddlebags $98-190 madman - Pinkphantom.com

* Hazard light less than $10 if u fix&wire urself, $18-20 for mech installation [[ S$15 if Replay does it for you! ]]

* Relocating rear signals to license plate - $10 (planet)

* Relocating rear signals to license plate with bracket - $28 (LAB)

* Rear box $80-330

* Voltage stabiliser - $59-$120 depends

* Rider's ORIGINAL footrest (LAB) - S$18 per side, can be cheaper?

* Stainless steel screws for speedo, and side covers. 6 to change altogether. $1-$1.80 also bought from koon.

* washers to go at 50c each at regina

* Socket for supporting the head light - $15

* Bullet Headlight - $35 (LAB)

* Gear lever with rubber $20 at koon

* Chrome gear and brake levers set - madman

* Stebel Magnum 2 (Silver) w/o installation - $18-$20 (LAB)

* Daiso electric horns (pair) - $45 (planet)

* Phantom TA 200 gearbox - $540 (planet)

* Front fender the "mudflap"- $20 at koon

* Stebel Electric horn with nice hidden installation under front chrome cover- at koon $38

* Re-wrap seat- Starts from about $38 from Eugene saddledry, $25 basic one from Auntie Shop

* Spotlights on crashbar with installation- $35 at koon

* Crashbar- $65 from ah boy DIY

* Anchor and wide type crashbar - madman

* rear no. plate $10..first shop opposite rov..ubi

 

Still looking for Phantom Custom4 badge...

Gonna visit scrapyards soon. For those interested in getting the addresses...

http://www.onemotoring.com.sg/publish/onemotoring/en/lta_information_guidelines/de_register_a_vehicle/de-register/scrap_yard_operators.html

 

btw are the girls from auntie shop twin sisters? lol[

[hu-am-i]

anyone knows if ah koon or planet does servicing in a package ? normally what is included in the package ?

[jtzx]

they no package.. u buy what you pay what.. just like a normal Shop.. they got no promotion or advertisment ;D

[hu-am-i]

they no package.. u buy what you pay what.. just like a normal Shop.. they got no promotion or advertisment ;D

 

alright thanks, but usually full servicing for phantom TA 200 will include what things changed ? what about the price ?

[hu-am-i]

they no package.. u buy what you pay what.. just like a normal Shop.. they got no promotion or advertisment ;D

 

alright thanks, but usually full servicing for phantom TA 200 will include what things changed ? what about the price ?

[m0bIlEnErD]

if change engine oil and plugs only pretty cheap. can DIY also. less than $20 if you DIY.

[Allen]

Anyone keen to teach me how to change engine oil and plugs? I wanna learn how to DIY :/

[Icomeforyou]

Actually ar... When you buy EO , already should have free change, so might as well change spark also.. Since its free and all, and at the same time can get the mech to blow your air filter

[CSV]

Anyone keen to teach me how to change engine oil and plugs? I wanna learn how to DIY :/

 

plugs very easy one, just need your phantom toolbox. like changing lightbulb.

 

change engine oil slightly more challenging, you will need a box to drain the old engine fluid into and locate the drain screw.

[naim]

guys.. can we change our handlebars to those straight drag-bar kind? which shops available? or can ours use sumting like a renthal bar? i want a relatively straight bar.. cux i tend to slouch (tired! n backache!), so i nd a handlebar wif less pull-back so dat i can sit more upright... thanks in advance!

[Hydher]

Anyone keen to teach me how to change engine oil and plugs? I wanna learn how to DIY :/

 

http://www.singaporebikes.com/forums/showthread.php/244355-Phantom-TA200-How-to-DIY-Guide(with-Pics)-Updated!-13-12-09

[Allen]

http://www.singaporebikes.com/forums/showthread.php/244355-Phantom-TA200-How-to-DIY-Guide(with-Pics)-Updated!-13-12-09

 

Is phantom TA150 same? as TA200?

[armani123sg]

guys.. can we change our handlebars to those straight drag-bar kind? which shops available? or can ours use sumting like a renthal bar? i want a relatively straight bar.. cux i tend to slouch (tired! n backache!), so i nd a handlebar wif less pull-back so dat i can sit more upright... thanks in advance!

 

straight bar also can slouch one. :-X but ah boy selling at $30...

[Hydher]

straight bar also can slouch one. :-X but ah boy selling at $30...

 

+ installation at $50 ah chong.

[Hydher]

Is phantom TA150 same? as TA200?

 

alot alike.

[naim]

+ installation at $50 ah chong.

 

straight bar also can slouch one. :-X but ah boy selling at $30...

 

i tink dat stretching further will help me straighten my posture a little.. cux i tried reversing the risers (facing forwards), but its a tad too far.. quite tiring.. so i tot i might be able to use the stock risers, but wif a straighter bar.. thx for the info btw.. will go n check it out..

 

but any differences wif d handling wen using a straight bar? isit like heavier steering?

[deathmaster]

Anyone keen to teach me how to change engine oil and plugs? I wanna learn how to DIY :/

 

If you want to diy, its useful to learn how to change the plug. but as for engine oil, know how to top up can alr lah.

Used engine oil cannot anyhow dispose as it is a toxic pollutant. so even if you change the oil yourself, you still have to bring it to the shop for disposal, may as well change at the shop better.

 

den as for plugs, its useful if you ever get stranded on the road. But i am a lazy person, and prefer to just change a plug every 5000km, since a plug's pretty cheap.

[Pandoras Kitten 3]

i tink dat stretching further will help me straighten my posture a little.. cux i tried reversing the risers (facing forwards), but its a tad too far.. quite tiring.. so i tot i might be able to use the stock risers, but wif a straighter bar.. thx for the info btw.. will go n check it out..

 

but any differences wif d handling wen using a straight bar? isit like heavier steering?

 

Straight bar - I don't think there would be drastically different handling, as the centre of gravity of the rider is only shifted a few cm at most. Only the ergonomics matter. I also prefer a "streetfighter" type riding posture slightly leaned forward and currently ride with slightly bent arms (got windscreen to use. Like racing phantom ) $30 for straight bar seems nice.

[OlieLove]

newby here...how do i raise the tank up? do i need to remove anything from the bike?

[wahwah90]

My back brakepump started to leak oil..need to replace the pump or can repair?

[GregTay67]

My back brakepump started to leak oil..need to replace the pump or can repair?

 

Definitely need to replace as soon as possible. Brake fluid is very corrosive.

[GregTay67]

Straight bar - I don't think there would be drastically different handling' date=' as the centre of gravity of the rider is only shifted a few cm at most. Only the ergonomics matter. I also prefer a "streetfighter" type riding posture slightly leaned forward and currently ride with slightly bent arms (got windscreen to use. Like racing phantom ) $30 for straight bar seems nice.[/quote']

 

I also thought of getting a straight bar but worried that leaning slightly more forward will make it less comfortable.

[armani123sg]

I also thought of getting a straight bar but worried that leaning slightly more forward will make it less comfortable.

 

the slight lean is the best feel ever bro!!! i have ALWAYS been a fan of wide handlebars... but when i tried my fren's straight bar, i fell in love with it! then when i ride m other fren wide handlebar, i still love it! so now, i like both the styles very much!

[jeffrey83]

Time for me to Top OVERHAUL according to Ah chong...

 

What is the price like huh? Planet only told me $300+..

 

Thanks!