[Discussion] Typical prices for Phantom repairs & mods

[gysmily]

You can go see doctor chong or go to Mepkoh clinic centre for advice. Both doesnt charge consultation fee.

 

btw like your nik "jbnewbike" remind me of someone here....lol

[ylsonny]

Repairs / Maintenance :

 

* Fuel Sensor $40 (Planet)custom 4 & above

* Battery $26-$30 (LAB) / $30-35 (Planet) / $48 (Ah Koon)

* Steering cone $55-65

* Chain Tensioner $55-60 (for tick tick sound at cold start)

* Front brake disc $45

* tyres (metz) $150 front & back

* Chain $70-120 depending on type

* Chain + Sprocket - $140+/-

* DID O RING with Original Honda Sprocket - $130 (Planet, did it this afternoon)

* signal lights - depending on which type you like. $8-25.

* signal bulb, headlight bulb - 1 $ (LAB, easy DIY) (add on: approved brighter ones for $8. bought from koon.)

* headlight - anywhere from $35 to 90 depending the type you like.

* Spark plug - $4-20 [[ Replay once had his changed for S$2 ]]

* Engine oil - $6 -18 (jB got his lousiest EO for $3)

* Brake Pad $20-25

* Air filter - $10

* wheel ball bearings - $20-35 (depends on how mech chop u)

* Gear Shaft - $100 (planet)

* Clutch plate - $80 (Planet)

* Front fork (1 pair) - $330 (planet)

* rectifier - $75 (planet)

* coil - $180 (planet)

* rethreading of spark plug thread - between $35 - $45.

* gasket - $35 (koon)

* starter carbon - $60 (planet)

* front fender - $45 (original honda)

* rear brake plate w/ pad $58 (planet)

* original rear suspension $180 (planet)

* repair front brake pump (jam) and replace brake oil -$25 - planet

* replace entire front brake pump ($80) - planet

* Rear Brake Pump ($85) (planet!)

 

Mods and Accessories:

 

* Wide handlebar (custom4 phantom type) - $38

* Wide Crashbar with mounting points for spotlights - $80

* Footrest - $65-85

- Front\Rubber part - $5/piece @LAB

- Front\Metal base plate - $11/piece @LAB

- Rear\Eagle footrest - $25/pair @ LAB

* side box e21 - $100-130

* fuel tank - $382 contact madman or check http://www.pinkphantom.com/estore06.html

* spotlights $35 a pair http://www.pinkphantom.com/estore11a.html

* windshield $65-80

* grips $20-120

* chrome w/ rubber strips grips (LAB) - $25

* mirrors $25-50 (jB got his, 8 bucks for small ones)

* look-alike-original mirrors (shop beside LAB) - $20, LAB should be cheaper.

* saddlebags $110-180

* hazard light less than $10 if u fix&wire urself, $18-20 for mech installation [[ S$15 if Replay does it for you! ]]

* rear box $80-150

* voltage stabiliser - $59-$120 depends

* pillion's 'eagle' footrest w/o installation (LAB) - S$22

* rider's ORIGINAL footrest (LAB) - S$18 per side, can be

cheaper?

* stainless steel screws for speedo, and side covers. 6 to change altogether. $1-$1.80 also bought from koon.

* Socket for supporting the head light - $15

* Bullet Headlight - $35 (LAB)

* Gear lever with rubber $20 at koon

* Stebel Magnum 2 (Silver) w/o installation - $18-$20 (LAB)

* Phantom TA 200 gearbox - $540 (*planet)

[Hydher]

Repairs / Maintenance :

 

*Rubber strip in between speedo and tank $3.50 (planet)

* Fuel Sensor $40 (Planet)custom 4 & above

* Battery $26-$30 (LAB) / $30-35 (Planet) / $48 (Ah Koon)

* Steering cone $55-65

* Chain Tensioner $55-60 (for tick tick sound at cold start)

* Chain Roller $10

* Front brake disc $45

* tyres (metz) $150 front & back

* Chain $70-120 depending on type

* Chain + Sprocket - $140+/-

* DID O RING with Original Honda Sprocket - $130 (Planet)

* signal lights - depending on which type you like. $8-25.

* signal bulb, headlight bulb - 1 $ (LAB, easy DIY) (add on: approved brighter ones for $8. bought from koon.)

* headlight - anywhere from $35 to 90 depending the type you like.

* Spark plug - $4-20 .Ngk $5 (planet)

* Engine oil - $5 -18

* Brake Pad $20-25

* Air filter - $10

* wheel ball bearings - $20-35 (depends on how mech chop u)

* Gear Shaft - $100 (planet)

* Clutch plate - $80 (Planet)

* Front fork (1 pair) - $330 (planet)

* rectifier - $75 (planet)

* coil - $180 (planet)

* rethreading of spark plug thread - between $35 - $45.

* gasket - $35 (koon)

* starter carbon - $60 (planet)

* front fender - $45 (original honda)

* rear brake plate w/ pad $58 (planet)

* original rear suspension $180 (planet)

* repair front brake pump (jam) and replace brake oil -$25 - planet

* replace entire front brake pump ($80) - planet

* Rear Brake Pump ($85) (planet!)

 

Mods and Accessories:

 

* Wide handlebar (custom4 phantom type) - $38

* Wide Crashbar with mounting points for spotlights - $80

* Footrest - $65-85

- Front\Rubber part - $5/piece @LAB

- Front\Metal base plate - $11/piece @LAB

- Rear\Eagle footrest - $25/pair @ LAB

* side box e21 - $100-130

* fuel tank - $382 contact madman or check http://www.pinkphantom.com/estore06.html

* spotlights $35 a pair http://www.pinkphantom.com/estore11a.html

* windshield $65-80

* grips $20-120

* chrome w/ rubber strips grips (LAB) - $25

* mirrors $25-50 (jB got his, 8 bucks for small ones)

* look-alike-original mirrors (shop beside LAB) - $20, LAB should be cheaper.

* saddlebags $110-180

* hazard light less than $10 if u fix&wire urself, $18-20 for mech installation [[ S$15 if Replay does it for you! ]]

* rear box $80-150

* voltage stabiliser - $59-$120 depends

* pillion's 'eagle' footrest w/o installation (LAB) - S$22

* rider's ORIGINAL footrest (LAB) - S$18 per side, can be

cheaper?

* stainless steel screws for speedo, and side covers. 6 to change altogether. $1-$1.80 also bought from koon.

* Socket for supporting the head light - $15

* Bullet Headlight - $35 (LAB)

* Gear lever with rubber $20 at koon

* Stebel Magnum 2 (Silver) w/o installation - $18-$20 (LAB)

* Phantom TA 200 gearbox - $540 (*planet)

[genie]

Replaced/bought earlier today (15 Oct 2008):

1. Chain tensioner - $65
   
2. Rear brakes - $25
   
3. Engine oil - $15
   
4. Spark plug - $10
   
5. Speedometer light bulb - free
   
6. Disc holder (for road tax/parking coupon etc.) - $1
   
7. Helmet visor - $12
   
8. Helmet - $26

[Mutaga]

hi. i wanna ask. how much to repair for the front suspension (fork seal)?

[Hydher]

Replaced/bought earlier today (15 Oct 2008):

1. Chain tensioner - $65
   
2. Rear brakes - $25
   
3. Engine oil - $15
   
4. Spark plug - $10
   
5. Speedometer light bulb - free
   
6. Disc holder (for road tax/parking coupon etc.) - $1
   
7. Helmet visor - $12
   
8. Helmet - $26

 

what brand eo, spark plug and helmet?

 

helmet visor $8 at ah boy kelantan lane

[chuan.z]

Replaced/bought earlier today (15 Oct 2008):

1. Chain tensioner - $65
   
2. Rear brakes - $25
   
3. Engine oil - $15
   
4. Spark plug - $10
   
5. Speedometer light bulb - free
   
6. Disc holder (for road tax/parking coupon etc.) - $1
   
7. Helmet visor - $12
   
8. Helmet - $26

 

10 bucks for a plug? NGK G-Power?

[EK]

any idea whr to get this set-up at a reasonable price?

 

http://img.photobucket.com/albums/v359/calm_guy/normal_headliteassembly0.jpg

 

another question is izzit easy to diy? help help plz

[TheYasMan]

any idea whr to get this set-up at a reasonable price?

 

http://img.photobucket.com/albums/v359/calm_guy/normal_headliteassembly0.jpg

 

another question is izzit easy to diy? help help plz

 

Madman lah... I think you can try getting his current one on his Pinky, since whatever was on the bike has been on sale since last year's SBBF. I considered getting it before but it was way beyond my budget. It's not easy to DIY at all.

[EK]

double post

[EK]

Madman lah... I think you can try getting his current one on his Pinky, since whatever was on the bike has been on sale since last year's SBBF. I considered getting it before but it was way beyond my budget. It's not easy to DIY at all.

 

hmm... when is madman's next open house? I believe last time got a convoy to go his house de.. i think last december

 

Another thing I scared is buy lei dunno how to DIY den dunno which mech to bring to

[thenation]

EK, there was a open house earlier this year, around march/april, can't remember exactly when. Anyway, his house is usually open as long as you inform him in advance. Oh, if you buy from him don't worry, he won't 'throw you to one side' when it comes to installation.

[EK]

EK, there was a open house earlier this year, around march/april, can't remember exactly when. Anyway, his house is usually open as long as you inform him in advance. Oh, if you buy from him don't worry, he won't 'throw you to one side' when it comes to installation.

 

oh ya.. tat time i was having my exams so cannot go... anyone gg madman place on weekends? maybe i can tag along never go his place before..

[TheYasMan]

hmm... when is madman's next open house? I believe last time got a convoy to go his house de.. i think last december

 

Another thing I scared is buy lei dunno how to DIY den dunno which mech to bring to

 

The typical person wont be able to DIY due to lack of appropriate tools, if not knowledge too. The last time he fixed it up for himself, he hired a freelancing mech friend. He also offered me an appointment with the mech to fix up my fork springs. Fix, sure can fix, dont worry.

[ahbeno3]

changed my clutch plate for TA 150 at $70. Planet!

[kzone]

Upz for this useful thread... juz changed Gasket at Koon for $30

 

 

Repairs / Maintenance :

 

* Fuel Sensor $40 (Planet)custom 4 & above

* Battery $26-$30 (LAB) / $30-35 (Planet) / $48 (Ah Koon)

* Steering cone $55-65

* Chain Tensioner $55-60 (for tick tick sound at cold start)

* Front brake disc $45

* tyres (metz) $150 front & back

* Chain $70-120 depending on type

* Chain + Sprocket - $140+/-

* DID O RING with Original Honda Sprocket - $130 (Planet, did it this afternoon)

* signal lights - depending on which type you like. $8-25.

* signal bulb, headlight bulb - 1 $ (LAB, easy DIY) (add on: approved brighter ones for $8. bought from koon.)

* headlight - anywhere from $35 to 90 depending the type you like.

* Spark plug - $4-20 [[ Replay once had his changed for S$2 ]]

* Engine oil - $6 -18 (jB got his lousiest EO for $3)

* Brake Pad $20-25

* Air filter - $10

* wheel ball bearings - $20-35 (depends on how mech chop u)

* Gear Shaft - $100 (planet)

* Clutch plate - $80 (Planet)

* Front fork (1 pair) - $330 (planet)

* rectifier - $75 (planet)

* coil - $180 (planet)

* rethreading of spark plug thread - between $35 - $45.

* gasket - $30 (koon)

* starter carbon - $60 (planet)

* front fender - $45 (original honda)

* rear brake plate w/ pad $58 (planet)

* original rear suspension $180 (planet)

* repair front brake pump (jam) and replace brake oil -$25 - planet

* replace entire front brake pump ($80) - planet

* Rear Brake Pump ($85) (planet!)

 

Mods and Accessories:

 

* Wide handlebar (custom4 phantom type) - $38

* Wide Crashbar with mounting points for spotlights - $80

* Footrest - $65-85

- Front\Rubber part - $5/piece @LAB

- Front\Metal base plate - $11/piece @LAB

- Rear\Eagle footrest - $25/pair @ LAB

* side box e21 - $100-130

* fuel tank - $382 contact madman or check http://www.pinkphantom.com/estore06.html

* spotlights $35 a pair http://www.pinkphantom.com/estore11a.html

* windshield $65-80

* grips $20-120

* chrome w/ rubber strips grips (LAB) - $25

* mirrors $25-50 (jB got his, 8 bucks for small ones)

* look-alike-original mirrors (shop beside LAB) - $20, LAB should be cheaper.

* saddlebags $110-180

* hazard light less than $10 if u fix&wire urself, $18-20 for mech installation [[ S$15 if Replay does it for you! ]]

* rear box $80-150

* voltage stabiliser - $59-$120 depends

* pillion's 'eagle' footrest w/o installation (LAB) - S$22

* rider's ORIGINAL footrest (LAB) - S$18 per side, can be

cheaper?

* stainless steel screws for speedo, and side covers. 6 to change altogether. $1-$1.80 also bought from koon.

* Socket for supporting the head light - $15

* Bullet Headlight - $35 (LAB)

* Gear lever with rubber $20 at koon

* Stebel Magnum 2 (Silver) w/o installation - $18-$20 (LAB)

* Phantom TA 200 gearbox - $540 (*planet)

[Hydher]

chrome casing how much?

[heskeydal]

Repairs / Maintenance :

 

* Fuel Sensor $40 (Planet)custom 4 & above

* Battery $26-$30 (LAB) / $30-35 (Planet) / $48 (Ah Koon)

* Steering cone $55-65

* Chain Tensioner $55-60 (for tick tick sound at cold start)

* Front brake disc $45

* tyres (metz) $150 front & back

* Chain $70-120 depending on type

* Chain + Sprocket - $140+/-

* DID O RING with Original Honda Sprocket - $130 (Planet, did it this afternoon)

* signal lights - depending on which type you like. $8-25.

* signal bulb, headlight bulb - 1 $ (LAB, easy DIY) (add on: approved brighter ones for $8. bought from koon.)

* headlight - anywhere from $35 to 90 depending the type you like.

* Spark plug - $4-20 [[ Replay once had his changed for S$2 ]]

* Engine oil - $6 -18 (jB got his lousiest EO for $3)

* Brake Pad $20-25

* Air filter - $10

* wheel ball bearings - $20-35 (depends on how mech chop u)

* Gear Shaft - $100 (planet)

* Clutch plate - $80 (Planet)

* Front fork (1 pair) - $330 (planet)

* rectifier - $75 (planet)

* coil - $180 (planet)

* rethreading of spark plug thread - between $35 - $45.

* gasket - $30 (koon)

* starter carbon - $60 (planet)

* front fender - $45 (original honda)

* rear brake plate w/ pad $58 (planet)

* original rear suspension $180 (planet)

* repair front brake pump (jam) and replace brake oil -$25 - planet

* replace entire front brake pump ($80) - planet

* Rear Brake Pump ($85) (planet!)

 

Mods and Accessories:

 

* Wide handlebar (custom4 phantom type) - $38

* Wide Crashbar with mounting points for spotlights - $80

* Footrest - $65-85

- Front\Rubber part - $5/piece @LAB

- Front\Metal base plate - $11/piece @LAB

- Rear\Eagle footrest - $25/pair @ LAB

* side box e21 - $100-130

* fuel tank - $382 contact madman or check http://www.pinkphantom.com/estore06.html

* spotlights $35 a pair http://www.pinkphantom.com/estore11a.html

* windshield $65-80

* grips $20-120

* chrome w/ rubber strips grips (LAB) - $25

* mirrors $12(LAB) - $50 (jB got his, 8 bucks for small ones)

* look-alike-original mirrors (shop beside LAB) - $20, LAB should be cheaper.

* saddlebags $110-180

* hazard light less than $10 if u fix&wire urself, $18-20 for mech installation [[ S$15 if Replay does it for you! ]]

* rear box $80-150

* voltage stabiliser - $59-$120 depends

* pillion's 'eagle' footrest w/o installation (LAB) - S$22

* rider's ORIGINAL footrest (LAB) - S$18 per side, can be

cheaper?

* stainless steel screws for speedo, and side covers. 6 to change altogether. $1-$1.80 also bought from koon.

* Socket for supporting the head light - $15

* Bullet Headlight - $35 (LAB)

* Gear lever with rubber $20 at koon

* Stebel Magnum 2 (Silver) w/o installation - $18-$20 (LAB)

* Phantom TA 200 gearbox - $540 (*planet)

[jianping]

Hi all, anyone know where to get cheap respray? wanna do a single colour black spray? anyone got any recommendation?

 

Thanks.

[oktray]

Hi fellow PKs, anyone knows whats the price range of rear brake disc only? (excluding brake pads) It is supposed to have a minimum thickness of 3.5mm but mine is about 2mm. Need to change it soon. Thanks in advance.

[thatone1]

original -$80 including brake pads

 

aftermarket -$50 including brake pads

 

@ planet motor 67474740 ah chong

 

you have to change the brake pads together.. less if you wanna discuss the price with ah chong w/o brake pads

[jiansheng]

I got mine at $90 (honda) at planet...like last week.

[holyrider]

what is the estimated price for changing clutch plate? any one change before? thanks

[Hydher]

$80. its written upstairs =.="

[st_gtti]

Repairs / Maintenance :

 

* Fuel Sensor $40 (Planet)custom 4 & above

* Battery $26-$30 (LAB) / $30-35 (Planet) / $48 (Ah Koon)

* Steering cone $55-65

* Chain Tensioner $55-60 (for tick tick sound at cold start)

* Front brake disc $45

* tyres (metz) $150 front & back

* Chain $70-120 depending on type

* Chain + Sprocket - $140+/-

* DID O RING with Original Honda Sprocket - $130 (Planet, did it this afternoon)

* signal lights - depending on which type you like. $8-25.

* signal bulb, headlight bulb - 1 $ (LAB, easy DIY) (add on: approved brighter ones for $8. bought from koon.)

* headlight - anywhere from $35 to 90 depending the type you like.

* Spark plug - $4-20 [[ Replay once had his changed for S$2 ]]

* Engine oil - $6 -18 (jB got his lousiest EO for $3)

* Brake Pad $20-25

* Air filter - $10

* wheel ball bearings - $20-35 (depends on how mech chop u)

* Gear Shaft - $100 (planet)

* Clutch plate - $80 (Planet)

* Front fork (1 pair) - $330 (planet)

* rectifier - $75 (planet)

* coil - $180 (planet)

* rethreading of spark plug thread - between $35 - $45.

* gasket - $30 (koon)

* starter carbon - $60 (planet)

* front fender - $45 (original honda)

* rear brake plate w/ pad $58 (planet)

* original rear suspension $180 (planet)

* repair front brake pump (jam) and replace brake oil -$25 - planet

* replace entire front brake pump ($80) - planet

* Rear Brake Pump ($85) (planet!)

 

Mods and Accessories:

 

* Wide handlebar (custom4 phantom type) - $38

* Wide Crashbar with mounting points for spotlights - $80

* Footrest - $65-85

- Front\Rubber part - $5/piece @LAB

- Front\Metal base plate - $11/piece @LAB

- Rear\Eagle footrest - $25/pair @ LAB

* side box e21 - $100-130

* fuel tank - $382 contact madman or check http://www.pinkphantom.com/estore06.html

* spotlights $35 a pair http://www.pinkphantom.com/estore11a.html

* windshield $65-80

* grips $20-120

* chrome w/ rubber strips grips (LAB) - $25

* mirrors $12(LAB) - $50 (jB got his, 8 bucks for small ones)

* look-alike-original mirrors (shop beside LAB) - $20, LAB should be cheaper.

* saddlebags $110-180

* hazard light less than $10 if u fix&wire urself, $18-20 for mech installation [[ S$15 if Replay does it for you! ]]

* rear box $80-150

* voltage stabiliser - $59-$120 depends

* pillion's 'eagle' footrest w/o installation (LAB) - S$22

* rider's ORIGINAL footrest (LAB) - S$18 per side, can be

cheaper?

* stainless steel screws for speedo, and side covers. 6 to change altogether. $1-$1.80 also bought from koon.

* Socket for supporting the head light - $15

* Bullet Headlight - $35 (LAB)

* Gear lever with rubber $20 at koon

* Stebel Magnum 2 (Silver) w/o installation - $18-$20 (LAB)

* Phantom TA 200 gearbox - $540 (*planet)

 

what is the estimated price for changing clutch plate? any one change before? thanks