[Discussion] Typical prices for Phantom repairs & mods

[VidaK]

Have anyone fix the ABS that ah koon is selling on your phantom..

 

the ABS give the same purpose as will not lock ur wheel..

but the effect is always there not like those real 1 that will actival when ur wheel is locked..

and the con of koon's ABS is that it will increase ur braking distance...

 

I have never liked Always Buang System...

 

Practice using more front brake than rear brake. Will be useful when you go for your class 2a/2 TP.

 

Start building your confidence for E.brake course now.

 

yes! there are no abs bikes at driving centres!

 

Hehehe.. well my recent skidding is because i jammed brake my front too much and lost control. so i tot if got abs i will have more control as the wheel wont lock... If you got control i think distance also you can counter it by trying to turn right or left lor... Cos once your wheel lock.. you turn your bike only sure buang...

 

abs can fail, even electronic ones... by depending on them you would probably take braking late for granted...

 

Ride more to understand your bike ;-)

 

[razali1980]

Hmm look like ABS really not a gd choice...

 

Ok next question. Have anyone did a full overhaul of the bike at planet? Change all gears and engine block... how much in total they charge and how long it take? Will ah chong T-Loan a bike while the overhaul take place?

[Guest B_E_N]

ben, so not advisable to get the ABS? cos actually i was thinking whether to get it or not. haha.

 

still wanna say.. up to u lo..

some like it some dun.. haha

ah koon abs very direct 1, wheel wun lock but braking distance increase

[weian]

haha okok i see. (:

[VidaK]

Hmm look like ABS really not a gd choice...

 

Ok next question. Have anyone did a full overhaul of the bike at planet? Change all gears and engine block... how much in total they charge and how long it take? Will ah chong T-Loan a bike while the overhaul take place?

 

no ah chong cannot t-loan a bike...

 

for such a massive task... the complete rebuild should be approaching 1k... assuming you replace all the parts...

[razali1980]

anyone know where to replace the rubber lining thingy between the fuel tank and the speedo?

[jtzx]

anyone know where to replace the rubber lining thingy between the fuel tank and the speedo?

 

u can get it replace any bike shop. not too ex thou

[st_gtti]

anyone know where to replace the rubber lining thingy between the fuel tank and the speedo?

 

Can b done at planet dude hmm the last time i change both lining is less den $20.

[weian]

i duno if there's a prob with the installation, but the other time i changed at planet, whenever i wash bike, water will keep leaking out from underneath the lining. =/

[SNapEl]

i duno if there's a prob with the installation, but the other time i changed at planet, whenever i wash bike, water will keep leaking out from underneath the lining. =/

 

That should be a good thing isn't it? If not the spaces under the chrome cover will be water logged

 

That lining is not there to keep things water tight but to stop the speedo chrome cover from rattling against your tank.

[weian]

eh? but the previous lining wasnt like this before. i tot it was supposed to be dual role. ):

[lycan]

That should be a good thing isn't it? If not the spaces under the chrome cover will be water logged

 

That lining is not there to keep things water tight but to stop the speedo chrome cover from rattling against your tank.

what will be the side effect if one didnt replace the lining?

[st_gtti]

what will be the side effect if one didnt replace the lining?

 

 

so long the old piece still around think there isnt any side effect at all but it will start to crack once the lining start hardening

[SNapEl]

eh? but the previous lining wasnt like this before. i tot it was supposed to be dual role. ):

 

Dual role? So you want to keep water in or keep it out?

If you want to keep water in... for drinking?

If you want to keep it out... The water seeps in more from else where...

[jtzx]

Dual role? So you want to keep water in or keep it out?

If you want to keep water in... for drinking?

If you want to keep it out... The water seeps in more from else where...

 

lol.. so funny the way you explain ;-)

[weian]

duno leh. i think last time it kept the water out.

[razali1980]

Guys, anyone here replace the metal thingy that is holding the speedo? I respray it on sunday but the bottom of it super duper rusty sia... So I tot of changing it. Anyone know where I can get it?? see the attached pic.

[jtzx]

Guys, anyone here replace the metal thingy that is holding the speedo? I respray it on sunday but the bottom of it super duper rusty sia... So I tot of changing it. Anyone know where I can get it?? see the attached pic.

 

no this part or that part.. is replace the whole speedo + the metal thing supporting it.. comes as a set.

 

you can try scrapyard for 2nd hand.

[jtzx]

Repairs / Maintenance :

* Fuel Sensor $40 (Planet)custom 4 & above

* Battery $26Yuasa/$38(plug and play) (LAB) / $35 (Planet) / $48 (Ah Koon)/ $60 woodlands road carltex (7Ah battery)

* Steering cone $55-65

* Chain Tensioner $55-60 (for tick tick sound at cold start)

* Front brake disc $45

* Tyres (metz lasertec) $160 front & back just changed on monday at planet

* Chain $70-120 depending on type

* Chain + Sprocket - $140+/-

* DID O RING with Original Honda Sprocket - $130 (planet)

* Signal lights - depending on which type you like. $8-25.

* Signal bulb, headlight bulb - 1 $ (LAB, easy DIY) (add on: approved brighter ones for $8. bought from koon.)

* Speedo BackLight + Workmanship (Planet) - S$2

* Headlight - anywhere from $35 to 90 depending the type you like.

* Spark plug - $2-20 [[ Replay once had his changed for S$2 ]]

* Engine oil - $6 -18 (jB got his lousiest EO for $3)

* Brake Pad $15-25

* Bleed and change brake fluid($10 each side)

* Air filter - $10

* Wheel ball bearings - $20-35 (depends on how mech chop u) jtzx: change for only $5 at planet

* Gear Shaft - $100 (planet)

* Clutch plate - $80 (Planet)

* Front fork (1 pair) - $330 (planet)

* Front fork seals (plus fork oil of course) - $65 (planet)

* Front fork tube (1 x) - $30 (planet)

* Rectifier - $75 (planet)

* Coil - $180 (planet)

* Rethreading of spark plug thread - between $35 - $45.

* Gasket - $30 (koon)

* Gasket @ Exhaust - $25 (Planet)

* Starter carbon - $60 (planet)

* Front fender - $45 (original honda) ($28 at ah boy, DIY 4 screws only)

* Rear brake plate w/ pad $58 (planet)

* Rear brake disc - $80 (planet)

* Original rear suspension $180 (planet)

* Repair front brake pump (jam) and replace brake oil -$25 - (planet)

* Replace entire front brake pump ($80) - (planet)

* Rear Brake Pump ($85) (planet)

* Overhaul: Piston+Ring+Block+Top gasket+EO+Plug - ($380) - (planet)

* Rear brake light 12 v 5w/18w $1 (planet)

* Clutch cable - $15 (planet) / $20 (ah koon)

* Throttle cable - $12 (planet)

* Front Brake/Clutch Lever - $8 each(planet)

* Balancer [the 2 silver thingies at the edge of your handlebars] - $15 (planet)

* Front fender -$45 (AMK HL motors)

* Spark plug cap - $18 (planet)

* regina gold chain, front & rear honda sprockets with installation at ah boy- $120

Mods and Accessories:

* Respray of bike, (front/rear mudguard + Tank) single color - $180 (H L Cycle)

* Wide handlebar (custom4 phantom type) - $38

* Wide Crashbar with mounting points for spotlights - $80

* Big Footrest - $60 madman - Pinkphantom.com

* Front\Rubber part - $5/piece @LAB

* Front\Metal base plate - $11/piece @LAB

* Rear\Eagle footrest - $25/pair @ LAB (just bought today, now is $30)

* Side box e21 - $90-130

* Zeus box 48L - $110 (Koon)

* Fuel tank - $382 contact madman or check http://www.pinkphantom.com/estore06.html

* Spotlights $35 a pair http://www.pinkphantom.com/estore11a.html

* Windshield $65-80

* Grips $10-120

* Chrome w/ rubber strips grips (LAB) - $25

* Mirrors $12(LAB) - $50 (jB got his, 8 bucks for small ones)

* Look-alike-original mirrors (shop beside LAB) - $20, LAB should be cheaper.

* Saddlebags $98-190 madman - Pinkphantom.com

* Hazard light less than $10 if u fix&wire urself, $18-20 for mech installation [[ S$15 if Replay does it for you! ]]

* Relocating rear signals to license plate - $10 (planet)

* Relocating rear signals to license plate with bracket - $28 (LAB)

* Rear box $80-330

* Voltage stabiliser - $59-$120 depends

* Rider's ORIGINAL footrest (LAB) - S$18 per side, can be cheaper?

* Stainless steel screws for speedo, and side covers. 6 to change altogether. $1-$1.80 also bought from koon.

* washers to go at 50c each at regina

* Socket for supporting the head light - $15

* Bullet Headlight - $35 (LAB)

* Gear lever with rubber $20 at koon

* Chrome gear and brake levers set - madman

* Stebel Magnum 2 (Silver) w/o installation - $18-$20 (LAB)

* Daiso electric horns (pair) - $45 (planet)

* Phantom TA 200 gearbox - $540 (planet)

* Front fender the "mudflap"- $20 at koon

* Stebel Electric horn with nice hidden installation under front chrome cover- at koon $38

* Re-wrap seat- Starts from about $38 from Eugene saddledry

* Spotlights on crashbar with installation- $35 at koon

* Crashbar- $65 from ah boy DIY

* Anchor and wide type crashbar - madman

Tow Services & Send for Inspection:

* Towing (to and fro) - $40 (Planet)

* Send for inspection - $60 (Planet)

[razali1980]

no this part or that part.. is replace the whole speedo + the metal thing supporting it.. comes as a set.

 

you can try scrapyard for 2nd hand.

 

Hahahaha... Ok ok.. but the list not listed. So anyone know wat is the price like for the whole speedo?

[jtzx]

normally ppl will just get a 2nd hand one. no point a brand new one. or u can just buy from and motor shop. they scrap older phantoms.

[icearmour]

am looking for a spare key with the plastic keyhole closing thing on the back of the key for my custom4 ta200...does anyone know where to get this???tried few key shops, none has it...

 

thanks..

[dancingbiker]

Hi, am thinking of changing the rear tyres for my TA200. Does anyone have any recommendations? Whats good and the price n place to get it installed? Thanks.

[dancingbiker]

Hi, am thinking of changing the rear tyres for my TA200. Does anyone have any recommendations? Whats good and the price n place to get it installed? Thanks.

[ckoonyin]

Hi, am thinking of changing the rear tyres for my TA200. Does anyone have any recommendations? Whats good and the price n place to get it installed? Thanks.

 

Usually the common ones are Metzler and Pirelli (dunno if i got the spelling correct)

 

I am using the Pirelli Demon; got it done @ Unique.

 

Hahahaha... Ok ok.. but the list not listed. So anyone know wat is the price like for the whole speedo?

 

Think i saw it @ Ah koon on monday; perhaps u can get and re-spray ureself? perhaps black or something?