[Discussion] Typical prices for Phantom repairs & mods

[VidaK]

That the air suction valve

 

hmmm... I must go and check my phantom first...

[royvon]

thumbssssssss up !!

[jtzx]

Repairs / Maintenance :

* Fuel Sensor $40 (Planet)custom 4 & above

* Battery $26Yuasa/$38(plug and play) (LAB) / $35 (Planet) / $48 (Ah Koon)/ $60 woodlands road carltex (7Ah battery)

* Steering cone $55-65

* Chain Tensioner $55-60 (for tick tick sound at cold start)

* Front brake disc $45

* Tyres (metz lasertec) $160 front & back just changed on monday at planet

* Rear Tyre (Metz) $90 @ planet

* Chain $70-120 depending on type

* Chain + Sprocket - $140+/-

* DID O RING with Original Honda Sprocket - $130 (planet)

* Signal lights - depending on which type you like. $8-25.

* Signal bulb, headlight bulb - 1 $ (LAB, easy DIY) (add on: approved brighter ones for $8. bought from koon.)

* Speedo BackLight + Workmanship (Planet) - S$2

* Headlight - anywhere from $35 to 90 depending the type you like.

* Spark plug - $2-20 [[ Replay once had his changed for S$2 ]]

* Engine oil - $6 -18 (jB got his lousiest EO for $3)

* Brake Pad $15-25

* Bleed and change brake fluid($10 each side)

* Air filter - $10

* Wheel ball bearings - $20-35 (depends on how mech chop u) jtzx: change for only $5 at planet

* Gear Shaft - $100 (planet)

* Clutch plate - $80 (Planet)

* Front fork (1 pair) - $330 (planet)

* Front fork seals (plus fork oil of course) - $65 (planet)

* Front fork tube (1 x) - $30 (planet)

* Rectifier - $75 (planet)

* Coil - $180 (planet)

* Rethreading of spark plug thread - between $35 - $45.

* Gasket - $30 (koon)

* Gasket @ Exhaust - $25 (Planet)

* Starter carbon - $60 (planet)

* Front fender - $45 (original honda) ($28 at ah boy, DIY 4 screws only)

* Rear brake plate w/ pad $58 (planet)

* Rear brake disc - $80 (planet)

* Original rear suspension $180 (planet)

* Repair front brake pump (jam) and replace brake oil -$25 - (planet)

* Replace entire front brake pump ($80) - (planet)

* Rear Brake Pump ($85) (planet)

* Overhaul: Piston+Ring+Block+Top gasket+EO+Plug - ($380) - (planet)

* Rear brake light 12 v 5w/18w $1 (planet)

* Clutch cable - $15 (planet) / $20 (ah koon)

* Throttle cable - $12 (planet)

* Front Brake/Clutch Lever - $8 each(planet)

* Balancer [the 2 silver thingies at the edge of your handlebars] - $15 (planet)

* Front fender -$45 (AMK HL motors)

* Spark plug cap - $18 (planet)

* regina gold chain, front & rear honda sprockets with installation at ah boy- $120

 

Mods and Accessories:

* Respray of bike, (front/rear mudguard + Tank) single color - $180 (H L Cycle)

* Wide handlebar (custom4 phantom type) - $38

* Wide Crashbar with mounting points for spotlights - $80

* Big Footrest - $60 madman - Pinkphantom.com

* Front\Rubber part - $5/piece @LAB

* Front\Metal base plate - $11/piece @LAB

* Rear\Eagle footrest - $25/pair @ LAB (just bought today, now is $30)

* Side box e21 - $90-180 / $180 as of April 2010 from LAB

* Zeus box 48L - $110 (Koon)

* Fuel tank - $382 contact madman or check http://www.pinkphantom.com/estore06.html

* Spotlights $35 a pair http://www.pinkphantom.com/estore11a.html

* Windshield $65-80

* Grips $10-120

* Chrome w/ rubber strips grips (LAB) - $25

* Mirrors $12(LAB) - $50 (jB got his, 8 bucks for small ones)

* Look-alike-original mirrors (shop beside LAB) - $20, LAB should be cheaper.

* Saddlebags $98-190 madman - Pinkphantom.com

* Hazard light less than $10 if u fix&wire urself, $18-20 for mech installation [[ S$15 if Replay does it for you! ]]

* Relocating rear signals to license plate - $10 (planet)

* Relocating rear signals to license plate with bracket - $28 (LAB)

* Rear box $80-330

* Voltage stabiliser - $59-$120 depends

* Rider's ORIGINAL footrest (LAB) - S$18 per side, can be cheaper?

* Stainless steel screws for speedo, and side covers. 6 to change altogether. $1-$1.80 also bought from koon.

* washers to go at 50c each at regina

* Socket for supporting the head light - $15

* Bullet Headlight - $35 (LAB)

* Gear lever with rubber $20 at koon

* Chrome gear and brake levers set - madman

* Stebel Magnum 2 (Silver) w/o installation - $18-$20 (LAB)

* Daiso electric horns (pair) - $45 (planet)

* Phantom TA 200 gearbox - $540 (planet)

* Front fender the "mudflap"- $20 at koon

* Stebel Electric horn with nice hidden installation under front chrome cover- at koon $38

* Re-wrap seat- Starts from about $38 from Eugene saddledry

* Spotlights on crashbar with installation- $35 at koon

* Crashbar- $65 from ah boy DIY

* Anchor and wide type crashbar - madman

Tow Services & Send for Inspection:

* Towing (to and fro) - $40 (Planet)

* Send for inspection - $60 (Planet)

[devil.L]

20inches, 0 pull back, one-of-a-kind flat ape hanger, anyone?

[deckard]

how much is your ape hanger and do you have a picture?

[devil.L]

how much as in, specs?

total rise is app 20inche, width 25+-, pull back 0.

price wise, im letting go at 200.

pictures i do, but its in my cam, not transfer yet..

wld post it whn its transfered..

interested? (:

[Shunpo]

hey all~

 

is there anyway to change the fuel tank cap cover solely?

how much would it cost ?

 

 

Kena prank by some bloody ginnas or *censored* !

They go and pluck the cap out.

[Bikee]

hey all~

 

is there anyway to change the fuel tank cap cover solely?

how much would it cost ?

 

 

Kena prank by some bloody ginnas or *censored* !

They go and pluck the cap out.

 

I bought mine from LAB. $35. Try bargaining if u have the time.

[ckoonyin]

hey all~

 

is there anyway to change the fuel tank cap cover solely?

how much would it cost ?

 

 

Kena prank by some bloody ginnas or *censored* !

They go and pluck the cap out.

 

Nowdays got idiots like that around.

 

That time my front brake pump cover also stolen.....den LAB doesn't see the cover.

 

End up i had to go to scrap yard to get one.

 

U can try the scrap yard too. Perhaps it might be cheaper?

 

But am not too sure how is ure key gonna fit though.

[Shunpo]

yea. too many imature kids around. nothing better to do and go around vandalising other people's property. makes them look "cool" I guess.

 

Hmm, mine is not the entire cap gone though, just the lid at the top that covers the key hole. Cant fix back right ? It's very loose if I try to insert it back, so most probably it's gone.

 

One of my fairing also kena stolen on the first day I got my bike. yay =.=

[lycan]

some idiot stolen my rider's left footrest, rubber + base plate...

[VidaK]

yea. too many imature kids around. nothing better to do and go around vandalising other people's property. makes them look "cool" I guess.

 

Hmm, mine is not the entire cap gone though, just the lid at the top that covers the key hole. Cant fix back right ? It's very loose if I try to insert it back, so most probably it's gone.

 

One of my fairing also kena stolen on the first day I got my bike. yay =.=

 

some idiot stolen my rider's left footrest, rubber + base plate...

 

this is no good... if it happened at your home carpark maybe you can consider covering the bike with a canvas...

[ckoonyin]

this is no good... if it happened at your home carpark maybe you can consider covering the bike with a canvas...

 

yea...unfortunately that is only a deterent.

 

If pple still wanna disturb, even alarm also useless.

[VidaK]

yea...unfortunately that is only a deterent.

 

If pple still wanna disturb, even alarm also useless.

 

once my bike is worth over 18k I would mount a cctv and aim at it 24/7

[pureice68]

this is no good... if it happened at your home carpark maybe you can consider covering the bike with a canvas...

 

Ya, my sentiments the same! Cover it to prevent eye goggling at your stuffs!

[pureice68]

once my bike is worth over 18k I would mount a cctv and aim at it 24/7

 

Might as well employ a security guard, hahaha...

[VidaK]

Might as well employ a security guard, hahaha...

 

at least the camera probably wouldn't fail me

[ckoonyin]

at least the camera probably wouldn't fail me

 

best if those allows u to check from any PC.

[pureice68]

best if those allows u to check from any PC.

 

Ya, we'd installed a couple previously over in sawadee-land's office to monitor the staffs and inventory. Quite good as you can spot check anytime and anywhere you want.

[J.C]

Repairs / Maintenance :

* Fuel Sensor $40 (Planet)custom 4 & above

* Battery $26Yuasa/$38(plug and play) (LAB) / $35 (Planet) / $48 (Ah Koon)/ $60 woodlands road carltex (7Ah battery)

* Steering cone $55-65

* Chain Tensioner $55-60 (for tick tick sound at cold start)

* Front brake disc $45

* Tyres (metz lasertec) $160 front & back just changed on monday at planet

* Rear Tyre (Metz) $90 @ planet

* Chain $70-120 depending on type

* Chain + Sprocket - $140+/-

* DID O RING with Original Honda Sprocket - $130 (planet)

* Signal lights - depending on which type you like. $8-25.

* Signal bulb, headlight bulb - 1 $ (LAB, easy DIY) (add on: approved brighter ones for $8. bought from koon.)

* Speedo BackLight + Workmanship (Planet) - S$2

* Headlight - anywhere from $35 to 90 depending the type you like.

* Spark plug - $2-20 [[ Replay once had his changed for S$2 ]]

* Engine oil - $6 -18 (jB got his lousiest EO for $3)

* Brake Pad $15-25

* Bleed and change brake fluid($10 each side)

* Air filter - $10

* Wheel ball bearings - $20-35 (depends on how mech chop u) jtzx: change for only $5 at planet

* Gear Shaft - $100 (planet)

* Clutch plate - $80 (Planet)

* Front fork (1 pair) - $330 (planet)

* Front fork seals (plus fork oil of course) - $65 (planet)

* Front fork tube (1 x) - $30 (planet)

* Rectifier - $75 (planet)

* Coil - $180 (planet)

* Rethreading of spark plug thread - between $35 - $45.

* Gasket - $30 (koon)

* Gasket @ Exhaust - $25 (Planet)

* Starter carbon - $60 (planet)

* Front fender - $45 (original honda) ($28 at ah boy, DIY 4 screws only)

* Rear brake plate w/ pad $58 (planet)

* Rear brake disc - $80 (planet)

* Original rear suspension $180 (planet)

* Repair front brake pump (jam) and replace brake oil -$25 - (planet)

* Replace entire front brake pump ($80) - (planet)

* Rear Brake Pump ($85) (planet)

* Overhaul: Piston+Ring+Block+Top gasket+EO+Plug - ($380) - (planet)

* Rear brake light 12 v 5w/18w $1 (planet)

* Clutch cable - $15 (planet) / $20 (ah koon)

* Throttle cable - $12 (planet)

* Front Brake/Clutch Lever - $8 each(planet)

* Balancer [the 2 silver thingies at the edge of your handlebars] - $15 (planet)

* Front fender -$45 (AMK HL motors)

* Spark plug cap - $18 (planet)

* regina gold chain, front & rear honda sprockets with installation at ah boy- $120

* air suction valve - $60

Mods and Accessories:

* Respray of bike, (front/rear mudguard + Tank) single color - $180 (H L Cycle)

* Wide handlebar (custom4 phantom type) - $38

* Wide Crashbar with mounting points for spotlights - $80

* Big Footrest - $60 madman - Pinkphantom.com

* Front\Rubber part - $5/piece @LAB

* Front\Metal base plate - $11/piece @LAB

* Rear\Eagle footrest - $25/pair @ LAB (just bought today, now is $30)

* Side box e21 - $90-180 / $180 as of April 2010 from LAB

* Zeus box 48L - $110 (Koon)

* Fuel tank - $382 contact madman or check http://www.pinkphantom.com/estore06.html

* Spotlights $35 a pair http://www.pinkphantom.com/estore11a.html

* Windshield $65-80

* Grips $10-120

* Chrome w/ rubber strips grips (LAB) - $25

* Mirrors $12(LAB) - $50 (jB got his, 8 bucks for small ones)

* Look-alike-original mirrors (shop beside LAB) - $20, LAB should be cheaper.

* Saddlebags $98-190 madman - Pinkphantom.com

* Hazard light less than $10 if u fix&wire urself, $18-20 for mech installation [[ S$15 if Replay does it for you! ]]

* Relocating rear signals to license plate - $10 (planet)

* Relocating rear signals to license plate with bracket - $28 (LAB)

* Rear box $80-330

* Voltage stabiliser - $59-$120 depends

* Rider's ORIGINAL footrest (LAB) - S$18 per side, can be cheaper?

* Stainless steel screws for speedo, and side covers. 6 to change altogether. $1-$1.80 also bought from koon.

* washers to go at 50c each at regina

* Socket for supporting the head light - $15

* Bullet Headlight - $35 (LAB)

* Gear lever with rubber $20 at koon

* Chrome gear and brake levers set - madman

* Stebel Magnum 2 (Silver) w/o installation - $18-$20 (LAB)

* Daiso electric horns (pair) - $45 (planet)

* Phantom TA 200 gearbox - $540 (planet)

* Front fender the "mudflap"- $20 at koon

* Stebel Electric horn with nice hidden installation under front chrome cover- at koon $38

* Re-wrap seat- Starts from about $38 from Eugene saddledry

* Spotlights on crashbar with installation- $35 at koon

* Crashbar- $65 from ah boy DIY

* Anchor and wide type crashbar - madman

Tow Services & Send for Inspection:

* Towing (to and fro) - $40 (Planet)

* Send for inspection - $60 (Planet)

[caydias]

anyone know how to DIY hazard light?

material required?

[VidaK]

anyone know how to DIY hazard light?

material required?

 

refer to the clinic thread... it should be helpful...

 

http://www.singaporebikes.com/forums/showthread.php?t=195464&page=22

[Umar Munshi]

Hey guys, I'm new to the Phantom and this forum.

 

I bought a TA200 recently and its a great ride! The only discomfort is that the pillion legrests are rather bent (senget) which hurts my pillion's legs after prolonged riding.

 

I went back to the shop I bought it from but was told that nothing can be done about it.. sigh. This is a real bummer so I hope some of you experienced Phantom riders can share some advice with me.

 

If possible, a fix would be good or if not then I prob have to buy new ones. Either way I have no idea where to do so.. heh

 

Thank a mill!

[Umar Munshi]

anyone please?

[fatmama]

hey bro, check out the 'typical prices for phantom repairs n mods' threat, you will be able to find out the price and where to get them.